Abstract:Cold protection for outdoor workers is crucial for their health and thermal safety in winter. Personal heating is considered an effective measure to solve the problem, which can significantly improve thermal comfort. However, according to the present studies, a uniform assessment of different personal heating measures is hard to obtain. This study explored four typical types of personal heating measures (electrically heated garment, electrically heated garment with an aerogel layer, electrically heated seat, and chemically heated insole) in different cold environments. Clothing insulation, effective heating power (P-eff), and heating efficiency (eta) were measured by a thermal manikin with a constant temperature in nine environmental conditions. Three levels of two critical environmental factors (air temperature (T-a): -5 degrees C, -10 degrees C, and -15 degrees C; air velocity (V-a): < 0.1 m/s, 0.5 m/s, and 1.0 m/s) were crossed orthogonally to form the nine environmental conditions. The results indicated that T-a had no significant effect on clothing insulation, while elevated V-a significantly decreased clothing insulation. When V-a increased from 0 m/s to 1 m/s, the air layer inside the garment was squeezed, causing a 0.6-0.9 clo decrease in total clothing insulation. Decreased T-a and elevated V-a reduced the P-eff and eta of electrical heating measures while they improved the P-eff and eta of chemical heating insoles. The P-eff and eta of the garment dropped to 8.2 W and 21%, respectively, at -15 degrees C and 1.0 m/s. In addition, the aerogel layer could effectively improve the P-eff and eta of the garment. The improvement was weakened by decreased T-a and elevated V-a. The corrective power values of personal heating measures in different environments were calculated to guide the design and application of personal heating.

Subjective Evaluation of the Thermal Insulation Property of the New Type Cold Weather Clothing for Naval Crew

Heat-Insulation Property Evaluation of thermal protective clothing and cold protective clothing usually used at workplaces

Experimental Investigation of the Thermal Insulation and Evaporative Resistance of Protective Clothing on a Thermal Manikin in a Hot Environment

Wear trial assessment of layer structure effects on vapor permeability and condensation in a cold weather clothing ensemble

Study on clothing insulation distribution between half-bodies and its effects on thermal comfort in cold environments

Study on the Performance of Personal Heating in Extremely Cold Environments Using a Thermal Manikin

Thermophysiological Effect of Clothing Temperature Control in Cold Environment During Exercise

Thermal response of human body with immersion suit in cold environment

Study on temperature adaptability of new cold clothing materials

Effects of moisture content and clothing fit on clothing apparent ‘wet’ thermal insulation: A thermal manikin study

Evaluation on the thermal performance of a certain special protective suit under normal pressure and low temperature water conditions

Psychological study on thermal responses in asymmetrical cold radiation environment

Experimental Study on Improvement Effect of a Cooling Vest on Thermal Comfort of Manufactory Workers

Physiological and Thermal Response to Real-Life Transient Conditions During Winter in Severe Cold Area

Thermal Insulation of Protective Clothing Materials in Extreme Cold Conditions

Numerical Investigation of Phase Change Protective Clothing

Thermal Insulations of Multilayer Clothing Systems Measured by A Bench Scale Test in Low Level Heat Exposures

Estimating Local Thermal Insulation of Clothing Garments: Modelling and Application

Measurements of the Additional Thermal Insulation of Aircraft Seat with Clothing Ensembles of Different Seasons

Typical Winter Clothing Characteristics And Thermal Insulation Of Ensembles For Older People In China

Study on Evaluation System of Thermal Protective Clothing Cooling Effect