Abstract:Organic Rankine cycle (ORC) plays an important role in addressing the issue of energy shortage and climate change. The condenser should release heat to the environment. Due to the seasonal and daily variations of ambient conditions, the condensation temperature, power consumption of the cooling system, the operation conditions of the working medium pump and expander would suffer drastic changes in different condensing ambient conditions. Therefore, the main aim of this study is to investigate the cross-seasonal performance of the organic Rankine cycle under variable condensation conditions. Simultaneously, the single screw expander with quasi two-stage expansion was used to improve the performance of ORC in different condensing ambient conditions. A model was developed to depict the variations of operation parameters of ORC system. The results show that the performance of ORC was adversely correlated with the wet-bulb temperature throughout the year. The net power and net efficiency can be reached at 8.04 kW and 11.31% when the wet-bulb temperature is 1.1 °C, respectively. Additionally, the variation in cooling water flow rate has little effect on the volumetric expansion process of the new single screw expander, but has a significant influence on the velocity expansion process, which increases by nearly 56.4%. Meanwhile, decreasing the pipeline impedance coefficients of cooling system can optimize ORC system performance effectively. It was also discovered that the isentropic efficiency of single screw expander decreases by only 8.68 percentage points during the expansion ratio increase from 3.31 to 11.54.

Characteristics of Variable Conditions of Screw Expander System Based on Organic Rankine Cycle

Optimization of Organic Rankine Cycle Involving Operating Conditions and Work Fluids and Heat Integration

Simultaneous Optimization of a Heat Exchanger Network and Operating Conditions of Organic Rankine Cycle

Analysis of a 1 Kw Organic Rankine Cycle Using a Scroll Expander for Engine Coolant and Exhaust Heat Recovery

Simulations on Organic Rankine cycle with quasi two-stage expander under cross-seasonal ambient conditions

Performance study of a twin-screw expander used in a geothermal organic Rankine cycle power generator

Experimental Investigation on the Performance of A Twin-Screw Expander Used in an Orc System

Development and Dynamic Characteristics of an Organic Rankine Cycle

A study on the single screw expander with exhaust kinetic energy utilization in organic Rankine cycle conditions

Performance Simulation of a Twin-screw Expander Using R513A as Working Fluid in Organic Rankine Cycle System

Experimental and Modeling Investigation of an Organic Rankine Cycle System Based on the Scroll Expander

Multi-condition Operating Characteristics and Optimization of a Small-Scale ORC System

Steady and Transient Operation of an Organic Rankine Cycle Power System

Operation and performance of a low temperature organic Rankine cycle

Performance Analysis of ORC Screw Expansion Power Generation Set in Different Regions and Seasons

Operation of an Organic Rankine Cycle Dependent on Pumping Flow Rates and Expander Torques

Non-steady thermodynamic characteristics of a pilot-scale organic Rankine cycle system with a thermally-driven pump

Experimental Study of the Organic Rankine Cycle under Different Heat and Cooling Conditions

Thermodynamic Analysis of A Low-Temperature Organic Rankine Cycle Power Plant Operating at Off-Design Conditions

Performance Comparison of Organic Rankine Cycle with Expansion from Superheated Zone or Two-Phase Zone Based on Temperature Utilization Rate of Heat Source

Experiment Study on Organic Rankine Cycle System Using Scroll Expander