Abstract:The removal of nitrogen and organics in a sequencing batch reactor (SBR) using hybrid media were investigated in this work. The hybrid media was made by the use of polyurethane foam (PU) cubes and powdered activated carbon (PAC). The function of activated carbon of hybrid media was to offer a suitable active site, which was able to absorb organic substances and ammonia, as well as that of PU was to provide an appropriated surface onto which biomass could be attached and grown. A laboratory-scale moving-bed sequencing batch reactor (SBR) was used for investigating the efficiency of hybrid media. The removal of nitrogen and organics for synthetic wastewater (COD; 490-1,627 mg/L, NH4(+)-N; 180-210 mg/L) were evaluated at different COD/N ratio and different anoxic phase conditions, respectively. The system was operated with the organic loading rate (OLR) of 0.1, 0.16, 0.24, and 0.28 kg COD/m3 day, respectively. Each mode based on OLR was divided as the periods of 45 days of operation time, except for third mode that was operated during 30 days. After acclimatization period, effluent total COD concentrations slightly decreased and the removal efficiency of organics increased to about 90% (COD; 70 mg/L) after 60 days and achieved 98% (COD; 30 mg/L) at the end of experiments. The organics reduction seemed to be less affected by shock loading since high organic loads did not affect the removal efficiency. The NIH4(+)-N concentrations in effluent showed almost lower than 1 mg/L and NO3(-)-N concentrations were high (150 mg/L) during a very low C/N ratio (C/N=2). Over 90% of T-N removal efficiency (T-N; 16 mg/L) was obtained during the last 20 days of the operation after controlling the COD/N ratio (C/N=7). The mixing condition and COD/N ratio at anoxic phase were determined as a main operating factors. In future, the optimal operating conditions of SBR system with hybrid media will be investigated from the view of maintaining a sufficient biomass to the hybrid media under the vigorous mixing conditions.

Study on Starch Synthetic Wastewater Treatment by SBR Process

SBR co-metabolism process for the advanced treatment of petrochemical wastewater

Experimental Research on Removal of Nitrogen and Phosphorus in Enhanced Sequencing Batch Reactor Activated Sludge Process

A Reformed SBR Technology Integrated with Two‐step Feeding and Low‐intensity Aeration for Swine Wastewater Treatment

Anaerobic Digestion and Post-Treatment of Swine Wastewater Using IC–SBR Process with Bypass of Raw Wastewater

Experiment Study of Coking-plant Wastewater Treatment by Anoxic-SBR Process

Improvement in Post-Treatment of Digested Swine Wastewater

Formation of Aerobic Granular in Pilot-scale SBR for Real Wastewater Treatment

Effect of the sludge granulation on nitrogen and phosphorus removal in SBR process

Comparison Study on Phosphorus Removal Between Single-stage Oxic Process and Anaerobic/Aerobic Process

Experimental study on straw pulp gray water treatment by ABR-SBR

Denitrifying Phosphorus-Accumulating SBR Combined with Low-Intensity Aeration Technology for Piggery Wastewater Treatment

Study on SBBR process for simulation swine wastewater treatment

ABR/Oxidation Ditch Process for Treatment of High-concentration Starch Wastewater

Effect of SBR on soy milk wastewater treatment

Treatment of High Strength Wastewater Containing High Concentrations of Ammonium using SBR Bioreactor

Study of nitrogen and organics removal in sequencing batch reactor (SBR) using hybrid media

Partial Nitrification and Enhanced Biological Phosphorus Removal in a Sequencing Batch Reactor Treating High-Strength Wastewater

Simultaneous Removal of Organic Matter and Nutrients from High Strength Organic Wastewater Using Sequencing Batch Reactor (SBR)

[Aerobic Sludge Granulation and Biological Phosphorus Removal in Different Operating Conditions of SBR].

Wastewater treatment by alkali bacteria and dynamics of microbial communities in two bioreactors