Abstract:A new multi-purpose modular small pressurized water reactor with once-through steam generators is being designed in China. Its key parameters are different from traditional large pressurized water reactor. There are sixteen once-through steam generators divided into two groups inside of the pressure vessel. The four coolant pumps are located on the periphery of the pressure vessel. The coolant is heated by the core and transported the heat to the secondary loop by once-through steam generators. The superheated steam is generated, and its dynamics are different from those of U-tube steam generators. The relationship between the reactor and turbine is also complicated and needs to investigate. The control strategies of traditional large pressurized water reactor cannot be applied directly to the small reactor with once-through steam generators. Therefore, it is necessary to investigate suitable control strategies of the multi-purpose modular small reactor with once-through steam generators.Three control strategies are proposed and investigated in this study: turbine-leading, reactor-leading and feedwater-leading. With the reactor-leading strategy, the reactor power is adjusted by moving the control rod. The coolant temperature follows the change of the reactor power. Feedwater flow is applied to regulate the steam pressure. The steam flow rate follows the change of the feedwater flow rate to satisfy the demand power. With the turbine-leading strategy, the steam valve is adjusted which will influence the steam flow to satisfy the demand power. The feedwater-leading control strategy is adjusting the feed water flow rate corresponding to the demand power which has been measured. And reactor power and turbine load vary with feedwater flow rate. Input-output pairings of the control systems are determined based on the different strategies and proportion-integral-derivative(PID) controllers are tuned to meet the control requirements.To evaluate the performance of control strategies, power maneuvering events including a 10%FP (Full Power) step change and a ramp change with a rate of 5%FP/min are simulated. The processes of important control parameters varying with time are compared and evaluated to obtain the suitable one. Conclusions can be drawn from the simulation analyses of the control performance. The reactor-leading control strategy is best for the base-load operation. The turbine leading control strategy is more suitable for load-following operation. The feedwater leading control strategy can be applied to load-following operation with smooth load adjustment.

Study and Application of Control Strategy for Primary Frequency Regulation of Once-Through Boiler

Research of Inertial Control Strategy of Wind Turbines under Low Frequency Situation of Hydro-dominated System

Primary frequency control ability of thermal power units with large capacity:simulation and experiment

Primary Frequency Control Ability Evaluation of Valve Opening in Thermal Power Units Based on Artificial Neural Network

Study on Optimization of PID for Feed-water Control System of RB Test in PWR Nuclear Power Station

Research on the optimization of primary frequency modulation parameters of high power units

Coordinated Control of Air-Conditioning Loads for System Frequency Regulation.

Primary Frequency Control Optimization of Coal-Fired Power Plants with High-Low Position Shafts: Employing a Revised Strategy with Power-Decoupling and Feedforward-Compensating

Performance enhancement and optimization of primary frequency regulation of coal‐fired units under boundary conditions

Research and Test of the Primary Frequency Control in Ultra-Supercritical Units under Feed Water Bypass Control of HP Heater

Identification and Simulation of a Supercritical Unit and Its Primary Frequency Modulation and Control System

Test and simulation of primary frequency regulation of 600MW sub-critical thermal power units with wide load operation

Analysis and Discussion on Primary Frequency Regulation of Gas Turbine and Combined Cycle

Influence of Boiler Model on Simulation of Primary Frequency Regulation of Thermal Power Units

Optimization on control strategy of feedwater pump for a 300 MW unit after frequency transformation

Study on a New Modeling Method for Primary Frequency Regulation of Ultra-Supercritical Thermal Power Units

A New Coordinated Control Strategy for Boiler-Turbine System of Coal-Fired Power Plant

Intelligent Control of Power-Plant Main Steam Pressure and Power Output.

Research on the Frequency Control Strategy of Hydro-thermal Power Generating Units

Optimization of Primary Frequency Regulation of 650MW Thermal Power Plant

Control Strategy Investigation For A Multi-Purpose Modular Small Pressurized Water Reactor With Once-Through Steam Generators