Abstract:Microbial cultures repurposing organic industrial residues for value-added metabolite production is pivotal for sustainable resource use. Highlighting polyunsaturated fatty acids (PUFAs), particularly gamma-linolenic acid (GLA), renowned for their nutritional and therapeutic value. Notably, Zygomycetes' filamentous fungi harbor abundant GLA-rich lipid content, furthering their relevance in this approach. In this study, the strain C. elegans NRRL Y-1392 was evaluated for its capability to metabolize glycerol and produce lipids rich in GLA under different culture conditions. Various carbon-to-nitrogen ratios (C/N = 11.0, 110.0, and 220.0 mol/mol) were tested in batch-flask cultivations. The highest GLA production of 224.0 mg/L (productivity equal to 2.0 mg/L/h) was observed under nitrogen excess conditions, while low nitrogen content promoted lipid accumulation (0.59 g of lipids per g of dry biomass) without yielding more PUFAs and GLA. After improving the C/N ratio at 18.3 mol/mol, even higher PUFA (600 mg/L) and GLA (243 mg/L) production values were recorded. GLA content increased when the fungus was cultivated at 12 °C (15.5% w/w compared to 12.8% w/w at 28 °C), but productivity values decreased significantly due to prolonged cultivation duration. An attempt to improve productivity by increasing the initial spore population did not yield the expected results. The successful scale-up of fungal cultivations is evidenced by achieving consistent results (compared to flask experiments under corresponding conditions) in both laboratory-scale (Working Volume-Vw = 1.8 L; C/N = 18.3 mol/mol) and semi-pilot-scale (Vw = 15.0 L; C/N = 110.0 mol/mol) bioreactor experiments. To the best of our knowledge, cultivation of the fungus Cunninghamella elegans in glycerol-based substrates, especially in 20 L bioreactor experiments, has never been previously reported in the international literature. The successful scale-up of the process in a semi-pilot-scale bioreactor illustrates the potential for industrializing the bioprocess.

Study on Fed-batch Culture of Strain Cunninghamella sp.to Produce Gamma-linolenic Acid by Nitrogen Starvation and Glucose Feeding

Study on Metabolic Law of #Gamma#- Linolenic Acid Produced by Cunninghamella Echinulata

Effects of cultivation conditions on the production of gamma-PGA with Bacillus subtilis ZJU-7.

Effects of Cultivation Conditions on the Production of γ-PGA with Bacillus subtilis ZJU-7

Study on Conditions of Lipid Produced by Cunninghamellaechinulata in Unsterilized Solid State Fermentation

Using Potato Starch Wastewater to Produce GLA with Cunninghamella Echinulata

Study on the application of pulp bleaching effluents in GLA production by Cunninghamella echinulata

Study of Different Parameters Affecting Production and Productivity of Polyunsaturated Fatty Acids (PUFAs) and γ-Linolenic Acid (GLA) by Cunninghamella elegans Through Glycerol Conversion in Shake Flasks and Bioreactors

Productivity of Γ-Linoleic Acid by Oleaginous Fungus Cunninghamella Echinulata Using a Pulsed High Magnetic Field

Breeding of a High Gamma-Linolenic Acid Yield Producing Strain

REGULATION OF GLUTAMINE SYNTHETASE IN GLUTAMINE PRODUCTION BY FERMENTATION OF Corynebacterium Glutamicum WITH In-Situ NITROGEN STARVATION AND GRADIENT FED NITROGEN

Fermentation Conditions Optimization of Γ-Linolenic Acid Production from Potato Starch Waste Water

A Novel Fed-Batch Strategy Enhances Lipid and Astaxanthin Productivity Without Compromising Biomass of Chromochloris Zofingiensis.

Kinetic Modelling of Γ-Linolenic Acid Production by Cunninghamella Echinulata

Fed-batch fermentation of Mucor circinelloides reveals significant improvement in biomass and lipid accumulation through performance evaluation, chemical analysis, and expression profiling

Fermentation process development of recombinant Hansenula polymorpha for gamma-linolenic acid production.

Growth and fatty acid composition of Nannochloropsis sp. grown mixotrophically in fed-batch culture.

A Study of Extraction Method of Lipid Produced by Cunninghamella Echinulata

Production of Gamma-Linolenic Acid in Pichia Pastoris by Expression of A Delta-6 Desaturase Gene from Cunninghamella Echinulata

Impact of carbon and nitrogen feeding strategy on high production of biomass and docosahexaenoic acid (DHA) by Schizochytrium sp. LU310.

Enhancement of Lipid Productivity with a Novel Two-Stage Heterotrophic Fed-Batch Culture of Chlorella Protothecoides and a Trial of CO2 Recycling by Coupling with Autotrophic Process