Abstract:Nowadays, the zero liquid discharge of flue gas desulfurization (FGD) wastewater from coal-fired units has attracted the attention of all countries in the world. The pretreatment methods generally have the problems of high operation cost, small treatment capacity, and poor flexibility. However, the membrane method can avoid the above problems. In the current research, it has not been found that someone directly uses submerged ultrafiltration to pretreat FGD wastewater. Therefore, this paper innovatively proposed to directly use ceramic ultrafiltration membrane to treat FGD wastewater, which can ensure effluent quality and improve the flexibility of the pretreatment system. In this paper, the performance of submerged ultrafiltration membrane for the filtration of FGD wastewater from a power plant was studied to optimize the filtration performance and improve the effluent quality. The effects of operating parameters such as membrane permeate flux, aeration rate and filtration/backwashing time combination on the membrane performance were studied. The results showed that when the filtration/backwashing time combination was 15 min/30 s, with the increased in permeate flux from 55 L/(m2·h) to 100 L/(m2·h), the steady transmembrane pressure (TMP) increased from 39 kPa to 70 kPa, and the fouling rate increased significantly from 4.5 kPa/h to 7.3 kPa/h; When the aeration rate increased from 10 m3/(m2·h) to 30 m3/(m2·h), the membrane pollution was much reduced. Excessive aeration rate cannot further alleviate the membrane pollution, but also brought greater energy consumption; Increasing backwashing time can effectively inhibit the formation of gel layer on the surface of the membrane and prolong the initial stage of low-pressure operation; The rejection of suspended solids (SS) and turbidity of the equipment studied in this paper can reach more than 99% under various working conditions, which can satisfy the water quality requirements of the subsequent steps. The submerged ultrafiltration membrane was suitable for the pretreatment of FGD wastewater because it can ensure the quality of permeate under the premise of long-term operation.

Wet Flue Gas Desulfurization Wastewater Treatment with Reclaimed Water Treatment Plant Sludge: a Case Study.

Centrifugal Dewatering of Blended Sludge from Drinking Water Treatment Plant and Wastewater Treatment Plant

Application of Coagulation and Full-Membrane Process in Municipal Reclaimed Water in Northern China: an Optimized Process

Treatment of Flue Gas Desulfurization Wastewater by a Coupled Precipitation-Ultrafiltration Process

Study on Enhanced Dewatering of Surplus Sludge from Municipal Wastewater Treatment Plant by Electroflocculation Process with Electrode Plates

Pilot‐scale Treatment of Waste‐water from Carbon Production by a Combined Physical–chemical Process

Primary Research of a New Zero-Liquid-Discharge Technology of Wet Flue Gas Desulfurization Wastewater by Low-Rank Heat from Flue Gas

Integrated Coagulation-Trickling Filter-Ultrafiltration Processes For Domestic Wastewater Treatment And Reclamation

Treatment of Wet FGD Wastewater by a Modified Chemical Precipitation Method Using a Solid Powder Reagent

Application of a Novel Strategy—advanced Fenton-chemical Precipitation to the Treatment of Strong Stability Chelated Heavy Metal Containing Wastewater

High Performance of Commercial PAC on the Simultaneous Desulfurization and Denitrification of Wastewater From a Coal-Fired Heating Plant

Reuse Of Sludge Wastewater In Water Plant By Enhanced Coagulation During Low Temperature And Low Turbidity Period

Highly Efficient Phosphorus Removal by a Novel Prolonged Stirring Pelleting Coagulation for Sludge Water Treatment

A Study on the Impact of Sludge Water on Biological Phosphorus Removal Process of the Municipal Wastewater Treatment Plant and Its Treatment Process

Application of Submerged Ultrafiltration in Pretreatment of Flue Gas Desulfurization Wastewater

Recovering chemical sludge from the zero liquid discharge system of flue gas desulfurization wastewater as flame retardants by a stepwise precipitation process

The Application of the Integrated Technology of Flocculation Combined with Precoating Filtration in Wastewater Reuse

Process Development of Flue Gas Desulphurization Wastewater Treatment in Coal-Fired Power Plants Towards Zero Liquid Discharge: Energetic, Economic and Environmental Analyses

Research on wet flue gas desulfurization by waste

Waste Heat Utilization from Boiler Exhaust Gases for Zero Liquid Discharge of Desulphurization Wastewater in Coal-Fired Power Plants: Thermodynamic and Economic Analysis

A Novel Technical Route Based on Wet Flue Gas Desulfurization Process for Flue Gas Dehumidification, Water and Heat Recovery