Abstract:Mannosylerythritol lipids are glycolipid biosurfactants with many interesting properties. Despite the general interest in those molecules and the need for a robust process, studies on their production in bioreactors are still scarce. In the current study, the fermentative production of MEL in a bioreactor with Moesziomyces aphidis was performed using a defined mineral salt medium. Several kinetic process parameters like substrate consumption rates and product formation rates were evaluated and subsequently enhanced by increasing the biomass concentration through an exponential fed-batch strategy. The fed-batch approaches resulted in two to three fold increased dry biomass concentrations of 10.9–15.5 g/L at the end of the growth phase, compared with 4.2 g/L in the batch process. Consequently, MEL formation rates were increased from 0.1 g/Lh up to around 0.4 g/Lh during the MEL production phase. Thus, a maximum concentration of up to 50.5 g/L MEL was obtained when oil was added in excess, but high concentrations of residual fatty acids were also present in the broth. By adjusting the oil feeding to biomass-specific hydrolysis and MEL production rates, a slightly lower MEL concentration of 34.3 g/L was obtained after 170 h, but at the same time a very pure crude lipid extract with more than 90% MEL and a much lower concentration of remaining fatty acids. With rapeseed oil as substrate, the ideal oil-to-biomass ratio for full substrate conversion was found to be around 10 g oil /g biomass . In addition, off-gas analysis and pH trends could be used to assess biomass growth and MEL production. Finally, kinetic models were developed and compared to the experimental data, allowing for a detailed prediction of the process behavior in future experiments.

Characterization, Enhancement and Modelling of Mannosylerythritol Lipid Production by Fungal Endophyte Ceriporia Lacerate CHZJU.

Production and Identification of Mannosylerythritol Lipid-a Homologs from the Ustilaginomycetous Yeast Pseudozyma Aphidis ZJUDM34.

Production and Characterization of a New Glycolipid, Mannosylerythritol Lipid, from Waste Cooking Oil Biotransformation by Pseudozyma Aphidis ZJUDM34.

Characterization and Inducing Melanoma Cell Apoptosis Activity of Mannosylerythritol Lipids-A Produced from Pseudozyma Aphidis

Production of Mannosylerythritol Lipids Using Oils from Oleaginous Microalgae: Two Sequential Microorganism Culture Approach

Efficient production of mannosylerythritol lipids by a marine yeast Moesziomyces aphidis XM01 and their application as self-assembly nanomicelles

Optimization of fermentation conditions for production of a novel antifungal metabolite by response surface methodology

[Advance in Glycolipid Biosurfactants--mannosylerythritol Lipids].

Characteristics of mannosylerythritol lipids and their environmental potential.

The fed-batch production of mannosylerythritol lipids by Ustilago maydis DSM 4500 from hydrophilic carbon sources

Optimization and Kinetic Modeling of a Fed-Batch Fermentation for Mannosylerythritol Lipids (MEL) Production With Moesziomyces aphidis

Moesziomyces spp. cultivation using cheese whey: new yeast extract-free media, β-galactosidase biosynthesis and mannosylerythritol lipids production

Substrates of Opposite Polarities and Downstream Processing for Efficient Production of the Biosurfactant Mannosylerythritol Lipids from Moesziomyces spp.

Tailor-made mannosylerythritol lipids: current state and perspectives

Metabolomic Evaluation of the Central Metabolic Pathways of Mannosylerythritol Lipid Biosynthesis in Moesziomyces antarcticus T-34.

Production of Mannosylerythritol Lipids (MELs) to be Used as Antimicrobial Agents Against S. aureus ATCC 6538

Mannosylerythritol Lipids: Dual Inhibitory Modes Against Staphylococcus Aureus Through Membrane-Mediated Apoptosis and Biofilm Disruption.

Improvement of Exo-Polysaccharides Production and Modeling Kinetics by Armillaria Luteo-Virens Sacc. in Submerged Cultivation

Ergosterol Production from Molasses by Genetically Modified Saccharomyces Cerevisiae

Antibacterial Activity and Mannosylerythritol Lipids Against Vegetative Cells and Spores of Bacillus Cereus

Direct conversion of dissolved air flotation sludge to mannosylerythritol lipids by Moesziomyces aphidis