Abstract:An ultrasonic technique was applied to formulation of two-phase water-in-paraffin oil emulsions loading a high-molecular polysaccharide chitosan (CS) and stabilized by an oil-soluble surfactant (Span80) at different operational conditions. The influence of chitosan molecular properties, phase volume ratio (phi(w)), Span80 volume fraction (phi(s)) and ultrasonic processing parameters were systemically investigated on the basis of mean droplet diameter (MDD) and polydispersity index (PDI) of emulsions. It was observed that the molecular weight (M-w) of CS was an important influential factor to MDD due to the non-Newtonian properties of CS solution varying with M-w. The minimum MDD of 198.5 nm with PDI of 0.326 was obtained with ultrasonic amplitude of 32% for 15 min at an optimum phi(w) of 35%, phi(s) of 8%, probe position of 2.2 cm to the top of emulsion, while CS with M-w of 400 kDa and deacetylation degree of 84.6% was used. The rise of emulsion viscosity and the reduction of negative zeta potential at phi(w) increasing from 5% to 35% were beneficial to obtain finer droplets and more uniform distribution of emulsions, and emulsion viscosity could be represented as a monotonically-decreasing power function of MDD at the same phi(w). FTIR analysis indicated that the molecular structure of paraffin oil was unaffected during ultrasonication. Moreover, the emulsions exhibited a good stability at 4 degrees C with a slight phase separation at 25 degrees C after 24 h of storage. By analyzing the evolution of MDD, PDI and sedimentation index (SI) with time, coalescence model showed better fitting results as comparison to Ostwald ripening model, which demonstrated that the coalescence or flocculation was the dominant destabilizing mechanism for such W/O emulsions encapsulating CS. This study may provide a valuable contribution for the application of a non-Newtonian macromolecule solution as dispersed phase to generate nano-size W/O emulsions via ultrasound, and widen knowledge and interest of such emulsions in the functional biomaterial field.

Improving the Stability of Phosphatidylcholine-Enhanced Nanoemulsions Using Octenyl Succinic Anhydride-Modified Starch.

Improving the Freeze–thaw Stability of Emulsions Via Combining Phosphatidylcholine and Modified Starch: A Combined Experimental and Computational Study

Improving the Physical and Oxidative Stability of Emulsions Using Mixed Emulsifiers: Casein-Octenyl Succinic Anhydride Modified Starch Combinations.

Fabrication of OSA starch/chitosan polysaccharide-based high internal phase emulsion via altering interfacial behaviors.

Preparation and Physico-Chemical Characterization of OSA-Modified Starches from Different Botanical Origins and Study on the Properties of Pickering Emulsions Stabilized by These Starches

Ultrasonic Assisted Water-in-oil Emulsions Encapsulating Macro-Molecular Polysaccharide Chitosan: Influence of Molecular Properties, Emulsion Viscosity and Their Stability.

Stability Mechanism of Two Soybean Protein-Phosphatidylcholine Nanoemulsion Preparation Methods from a Structural Perspective: A Raman Spectroscopy Analysis

Effect of Cellulose Nanocrystals on the Formation and Stability of Oil-in-water Emulsion Formed by Octenyl Succinic Anhydride Starch

Study of Octenyl Succinic Ester of Soybean Soluble Polysaccharide and Its Emulsifying Stability

Preparation and Characterization of Nano-sized Emulsions Produced from Acid-soluble Soy Protein and Polysaccharide Complexes

Oxidized High-Amylose Starch As Pickering Stabilizer for Oil-in-water Emulsion and Delivery of Bioactive Compound

Formation, stability and the application of Pickering emulsions stabilized with OSA starch/chitosan complexes

Stabilizing Oil-in-Water Emulsion with Amorphous and Granular Octenyl Succinic Anhydride Modified Starches.

Preparation and stabilization of emulsions stabilized by mixed sodium caseinate and soy protein isolate

Micro‐ and Nano‐emulsions Based on Soluble Soy Polysaccharide and Octenyl Succinic Anhydride Modified Soluble Soy Polysaccharide

The effect of octenyl succinic anhydride-modified chitosan coating on DHA-loaded nanoemulsions: Physichemical stability and in vitro digestibility

Molecular Structures of Octenyl Succinic Anhydride Modified Starches in Relation to Their Ability to Stabilize High Internal Phase Emulsions and Oleogels

Physical Stability of Oil-in-water Multi-Layered Coenzyme Q10 Nano-Emulsions

Improving the emulsification performance of adlay seed starch by esterification combined with ultrasonication and enzymatic treatment

Stable Nano-Sized Emulsions Produced from Soy Protein and Soy Polysaccharide Complexes

Stable Oil-in-Water Emulsions Prepared from Soy Protein−Dextran Conjugates