Abstract:Volatile organic compounds (VOCs) emitted into the atmosphere negatively affect the environment and human health. Biotrickling filtration, an effective technology for treating VOC-laden waste gases, faces challenges in removing hydrophobic VOCs due to their low water solubility and therefore limited bioavailability to microorganisms. Consequently, the addition of (bio)surfactants has proven to be a promising strategy to enhance the removal of hydrophobic VOCs in biotrickling filters (BTFs). Yet, up to now, no single study has ever performed a mass transfer characterization of a BTF under (bio)surfactants addition. In this study, the effect of (bio)surfactant addition on the gas-liquid mass transfer characteristics of two BTFs was measured by using oxygen (O2) as a model gas. Through an empirical correlation, the mass transfer coefficients (kLa) of two hydrophobic VOCs, toluene and hexane, which are of industrial and environmental significance, were estimated. One BTF was filled with expanded perlite, while the other with a mixture of compost and wood chips (C + WC). Both BTFs were operated under different liquid velocities (UL: 0.95 and 1.53 m h-1). Saponin, a biological surfactant, and Tween 80, a synthetic surfactant, were added to the recirculating liquid at different critical micelle concentrations (CMCs: 0-3 CMC). The higher interfacial and surface area of the perlite BTF compared to the C + WC BTF led to higher kLaO2 values regardless of the operational condition: 308 ± 18-612 ± 19 h-1 versus 42 ± 4-177 ± 24 h-1, respectively. Saponin addition at 0.5 and 1 CMC had positive effects on the perlite BTF, with kLaO2 values two times higher compared to those at 0 CMC. Tween 80 exhibited a neutral or slightly positive effect on the mass transfer of both BTFs under all conditions. Overall, the CMC, along with the physical characteristics of the packing materials and the operational conditions evaluated explained the results obtained. This study provides fundamental data essential to improve the performance and design of BTFs for hydrophobic VOCs abatement.

Comparison of physical technologies for biomass control in biofilters treating gaseous toluene.

Chemical Removal of Excess Biomass from Biofilters

A New Biomass Control Method Using Ozone in Biofilters Treating Gaseous VOCs

Effect of operating conditions on long-term performance of a biofilter treating gaseous toluene: Biomass accumulation and stable-run time estimation

Simulation of Biomass Accumulation Pattern in Vapor-Phase Biofilters

Study on Gaseous Chlorobenzene Treatment by a Bio-Trickling Filter: Degradation Mechanism and Microbial Community

Biomass accumulation and control strategies in gas biofiltration.

An approach to purification of toluene waste gas by a cross-flow bio-trickling filter

Mesophilic and thermophilic biofiltration of gaseous toluene in a long-term operation: performance evaluation, biomass accumulation, mass balance analysis and isolation identification.

Purification of Low Concentration Toluene Waste Gas by an Enlarged Cross-Flow Bio-Trickling Filter

A Comparative Study of Bacterial and Fungal‐bacterial Steady‐state Stages of a Biofilter in Gaseous Toluene Removal: Performance and Microbial Community

Removal of Ternary VOCs in Air Streams at High Loads Using a Compost-Based Biofilter

Effect of surfactant type and concentration on the gas-liquid mass transfer in biotrickling filters used for air pollution control

Removal of Toluene Waste Gas by a Cross-flow Trickling Biofilter

Biodegradation of gaseous toluene with mixed microbial consortium in a biofilter: steady state and transient operation

Study of the Performance of Biotrickling Filter for Removing Toluene Waste Gas

Treatment of Hydrophobic Volatile Organic Compounds Using Two-Liquid Phase Biofilters

[Removal of Toluene Waste Gas by Pseudomonas Putida with a Bio-Trickling Filter].

Comparative study of the eliminating of waste gas containing toluene in twin biotrickling filters packed with molecular sieve and polyurethane foam.

Removal of Toluene from Air Streams Using A Gas-Liquid-Solid Three-Phase Airlift Loop Bioreactor Containing Immobilized Cells

Removal of Volatile Organic Compounds Using Biofilter