Abstract:PurposeThis paper presents a back-stepping sliding mode control method for vehicle suspension system with magnetorheological damper to obtain both the true nominal optimal suspension performance and better robustness. Through the study of control method, the acceleration of sprung mass is reduced, that is, the vertical vibration of vehicle is suppressed.MethodsA back-stepping sliding mode controller based on the establishment of the quarter-body MR suspension dynamic model, and it used the approximateskyhook-damping system as the reference model. The error dynamic equation is obtained through the MR suspension model and the reference model, and the error dynamic component is used as the back-stepping control parameter. On the premise of ensuring the system is asymptotically stable, adding the sliding mode surface to the dynamic equation of the third error subsystem can complete design of the back-stepping sliding mode controller. By constructing a magnetorheological damper experimental platform and then collecting the measured data, the improving hyperbolic tangent model of MR damper is presented. Furthermore, the Particle Swarm Optimization (PSO) method is proposed to find the improving hyperbolic tangent model’s optimal parameters to get the MR damper models.ResultsThe proposed semi-active suspension control system is rigorously proven to be input-to-state stable by virtue of Lyapunov stability theory. Through the simulation and experimental verification, it is proved that back-stepping sliding mode controller can reduce the acceleration of the sprung mass, that is, suppress the vertical vibration of the vehicle. At the same time, it is proved that the forward and inverse model of MR damper is effective, and can be applied to the hardware in the loop control experiment.ConclusionThe back-stepping sliding mode proposed in this paper is better than the seat suspension under other control and passive systems, which proves that the back-stepping sliding mode controller is effective. It also shows that the forward and inverse model of MR damper is effective.

Response time effect of magnetorheological dampers in a semi-active vehicle suspension system: performance assessment with quantitative feedback theory

Dynamic Characteristics and Modeling of A New Magnetorheological Damper for Broadband Vibration Control

Bounded Time-Delay Control Performance of Two-Degree-of-freedom Nonlinear Vehicle System under Random Road Excitation Using MR Damper

Adaptive Control for Suspension System of In-Wheel Motor Vehicle with Magnetorheological Damper

Research on time delay compensation control of Taylor series backstepping for magnetorheological semi-active suspension

Performance Evaluation of a Single Sensor Control Scheme Using a Twin-Tube MR Damper Based Semi-active Suspension

Gray skyhook predictive control of magnetorheological semi-active seat suspension with time delay

Semi-active fuzzy cooperative control of vehicle suspension with a magnetorheological damper

Modern Semi-Active Control Schemes for a Suspension with MR Actuator for Vibration Attenuation

The Response Time Of A Magnetorheological Fluid Squeeze Film Damper Rotor System

Road disturbances rejection of a semi-active vehicle suspension

A New Rotary Magnetorheological Damper for a Semi-Active Suspension System of Low-Floor Vehicles

Development of a Semi-Active Suspension Using a Compact Magnetorheological Damper with Negative-Stiffness Components

A New Generation of Magnetorheological Vehicle Suspension System With Tunable Stiffness and Damping Characteristics

Driving Safety Improved with Control of Magnetorheological Dampers in Vehicle Suspension

Back-Stepping Sliding Mode Controller Design for Vehicle Seat Vibration Suppression Using Magnetorheological Damper

Dynamic Analysis of a Quarter Car Model with Semi-Active Seat Suspension Using a Novel Model for Magneto-Rheological (MR) Damper

Control and Simulation of Semi-Active Suspension Based on MRF Damper

Active Force Control for Semi-Active Suspension with Magnetorheological Damper

Experimental Study on the Semi-Active Control Strategies of Magnetorheological Damper

An adaptive backstepping sliding mode control strategy for the magnetorheological semi-active suspension