Abstract:The cost and endurance anxiety about proton exchange membrane fuel cells (PEMFCs) has prompted the rapid development of platinum-based (Pt-based) oxygen reduction electrocatalysts towards smaller particle sizes, higher durability and alloying. However, well-balanced these advanced trends by a simple approach is difficult in practice, because the existing solutions are problematic in removing the protective organic coating or oxide shell that preventing the high-temperature agglomeration of Pt-based nanocrystals, or broadening the size range of Pt-based nanocrystals which caused by the heterogeneous distribution of heteroatom anchor points on supports. With a self-developed strategy that based on the atomic layer deposition (ALD), we have addressed these problems in two aspects. One is directly loading size and distribution controllable Pt nanocrystals on diverse supports, and another is indirectly depositing easily removed ultra-thin metal oxide coating with dual functions on prefabricated ultrasmall Pt nanocrystals to restrain their sintering effect during high temperature ordering. By controlling the temperature and pulse time of ALD, we successfully synthesized ultrasmall (< 2 nm) Pt nanocrystals on surface inactive TiC nanoparticles and nanowires. These two new electrocatalysts exhibited comparable oxygen reduction activity and durability on par with commercial Pt/C with lower Pt loading. And using this strategy, about 1 nm ZnO coating on Pt nanocrystals was performed to construct uniform PtZn intermetallic nanocrystals with the ultrasmall size of 2.50 ± 0.65 nm and excellent stability for oxygen reduction reaction. The mass activity of PtZn intermetallic nanocrystals reaches to 0.60 A mgPt -1 at 0.9 V (6 times than commercial Pt/C) and only 13 mV decrease of half-wave potential after 30000 cycles of accelerated durability testing rivaling the most recently reported PtZn catalysts. Ultrasmall sizes and excellent features of our Pt and Pt-based intermetallic nanocrystals are all attributed to the accurate control of ALD and could be a promising method applying to other Pt-based intermetallic nanocrystals.

Scalable Atomic‐Layer Tailoring of Abundant Oxide Supports Unlocks Superior Interfaces for Low‐Metal‐Loading Dehydrogenation

Optimizing Alkyne Hydrogenation Performance of Pd on Carbon in Situ Decorated with Oxygen-Deficient TiO2 by Integrating the Reaction and Diffusion

Ultrathin Coating of Confined Pt Nanocatalysts by Atomic Layer Deposition for Enhanced Catalytic Performance in Hydrogenation Reactions

(Digital Presentation) an Efficient and Stable of Low-Pt Catalysts for Full Water Splitting in Acidic

A Hydrothermally Stable Single-Atom Catalyst of Pt Supported on High-Entropy Oxide/Al 2 O 3 : Structural Optimization and Enhanced Catalytic Activity

(Digital Presentation) Controllable Preparation of Ultrasmall Pt-Based Intermetallic Nanocrystals Via Atomic Layer Deposition for Hydrogen Fuel Cell

Pt Catalysts Supported on H2 and O2 Plasma-Treated Al2O3 for Hydrogenation and Dehydrogenation of the Liquid Organic Hydrogen Carrier Pair Dibenzyltoluene and Perhydrodibenzyltoluene

A Hydrothermally Stable Single-Atom Catalyst of Pt Supported on High-Entropy Oxide/Al2O3: Structural Optimization and Enhanced Catalytic Activity.

Ultrathin Atomic Layer Deposited Al2O3 Overcoat Stabilizes Al2O3-Pt/Ni-Foam Hydrogenation Catalysts

Batch and continuous synthesis of well-defined Pt/Al2O3 catalysts for the dehydrogenation of homocyclic LOHCs

Enhanced O2 Reduction on Atomically Thin Pt-based Nanoshells by Integrating Surface Facet, Interfacial Electronic, and Substrate Stabilization Effects

Layered Double Hydroxide Derived Nial-Oxide Hollow Nanospheres For Selective Transfer Hydrogenation With Improved Stability

Zero-oxidation state precursor assisted fabrication of highly dispersed and stable Pt catalyst for chemoselective hydrogenation of α,β-unsaturated aldehydes

Highly Active Bimetallic MOF Derivatives for Improving the Dehydrogenation Performance of LiAlH4

Enhancing electron interaction between Pt and support for superior electrochemical performance through atomic layer deposition of tungsten oxide

Topotactic Reduction of Layered Double Hydroxides for Atomically Thick Two-Dimensional Non-Noble-metal Alloy

Insights into Size Effects of Pt/Al2O3 Catalysts on Hydrogen Production from Methylcyclohexane Dehydrogenation

Synergistic structural and electronic influences of Pt bead catalysts on dehydrogenation activity for liquid organic hydrogen carriers

The Effects of Alumina Morphology and Pt Electron Property on Reversible Hydrogenation and Dehydrogenation of Dibenzyltoluene As a Liquid Organic Hydrogen Carrier

Unraveling Hydrogenation Kinetic Behavior of Transition Metal Oxides Via Decoupling Dihydrogen Dissociation and Substrate Activation

High Oxygen Reduction Efficiency and Durability of Nano‐Honeycomb Pt3(NiFeCo) Replenished by High‐Entropy Metallic Glass Support