Abstract:This paper firstly presents an extended sliding mode observer (ESMO) for the electro-hydraulic servo systems (EHSSs) to deal with nonlinear factors like the external disturbance, parameter uncertainties as well as unmodeled characteristics in the EHSS. The model for the EHSS is established by taking these nonlinear factors into consideration and then the statespace representation is obtained. According to the state space, the ESMO for the EHSS is presented, the equivalence principle is properly utilized to simplify the ESMO and some saturation functions are employed to eliminate high frequency interferences caused by the chattering phenomenon. Based on estimated values from the ESMO, a robust adaptive backstepping controller (RABC) is presented in detail with taking some parameter uncertainties into consideration to further improve the tracking performance. The proposed controller has the following advantages: (1) utilizing the ESMO to cope with these nonlinear factors; (2) parameter online adaptive laws are employed in the RABC design to further improve the tracking performance. In order to verify the performance of the proposed controller, an experiment bench was established. Two sine waves reference signal (one amplitude 0.01 m, 1 Hz; the other 0.015 m, 2 Hz) are employed to verify the performance of the controller. Comparative experimental results show that: (1) the tracking performance of the proposed controller is better than that of a DOs based BC, a BC and a PI controller; (2) estimation values from the ESMO contains fewer noise than two conventional disturbance observers (DOs), which will decrease the control input ripples.

Eso-Based Adaptive Robust Control of Dual Motor Driving Servo System

Adaptive Robust Sensorless Control for PMSM Based on Improved Back EMF Observer and Extended State Observer

Backstepping Robust Adaptive Control for an Electro-Hydraulic Servo System

Adaptive Robust Control for Four-Motor Driving Servo System with Uncertain Nonlinearities

Adaptive Robust Control of a Class of Motor Servo System with Dead Zone Based on Neural Network and Extended State Observer.

Recursive Adaptive Integral Sliding Mode Control Based on Extended State Observer for Dual-Motor Servo System

Adaptive Robust Control for Servo System with Friction and Input Dead-Zone Nonlinearity

Adaptive Robust Control for Servo Mechanisms with Partially Unknown States Via Dynamic Surface Control Approach

Direct Optimization Based Compensation Adaptive Robust Control of Nonlinear Systems with State and Input Constraints

High-Order Fully Actuated Control Approach for Servo Systems Based on Dynamical Compensator and Extended State Observer

Time-Optimal Constrained Adaptive Robust Control of Single-DOF Mechanical Systems: A Comparative Study with BLF-based Methods

Adaptive robust control with extended state observer for human-robot impedance

On the design of extended state observer-based robust finite controller: For underactuated robotic system with multiple sources of uncertainties

Robust ESO Two-Degree-of-Freedom Control Design for Permanent Magnet Synchronous Motor

Extended sliding mode observer based robust adaptive backstepping controller for electro-hydraulic servo system: Theory and experiment

Extended State Observer Based Robust Adaptive Control on SE(3) for Coupled Spacecraft Tracking Maneuver with Actuator Saturation and Misalignment

Dual extended state observer-based backstepping control of electro-hydraulic servo systems with time-varying output constraints

Adaptive robust controller for servo system based on LuGre model of friction

Non-Linear Bandwidth Extended-State-Observer Based Non-Smooth Funnel Control for Motor-Drive Servo Systems

Enhanced command filtered control with extended state observer for dual‐motor servo mechanisms considering backlash and friction

A Compound Method Based on Extended Disturbance Observer and Adaptive Robust Control for Motion Control of Dc Motors