Abstract:As a renewable fuel, the application of biomass fuel gets more and more attention. Fire and explosion are the main safety problems in the biomass fuel storage process. The characteristic parameters and kinetic analysis of pyrolysis and combustion are significant to guide the safe storage of biomass fuel. In this work, the thermogravimetric analysis (TGA) was used to obtain the pyrolysis and combustion characteristics of corn straw powder, poplar wood chip and rice husk in nitrogen and air, respectively. The Thermogravimetry-Differential Thermogravimetric (TG-DTG) profile shows that the pyrolysis process of these biomass includes three stages of drying, pyrolysis and carbonization, while the combustion process includes three stages of drying, devolatilization and coke combustion. The main reaction stage of biomass pyrolysis and combustion are roughly between 170∼400 °C and 180∼530 °C, respectively. With the increase of the heating rate, TG and DTG profiles shifts to the high temperature side. Furthermore, the kinetic analysis was performed by using Kissinger-Akahira-Sunose (KAS), Flynn-Wall-Ozawa (FWO), Friedman, and Coats-Redfern (CR) methods, based on the thermogravimetric experimental data. The activation energy of biomass pyrolysis is shown to be between 70∼100 kJ/mol. For the activation energy of biomass combustion, the calculated value from isoconversional methods is between 140∼180 kJ/mol. The calculated value from CR method is between 80∼150 kJ/mol, and the activation energy of the coke combustion stage is greater than that of the devolatilization stage. Finally, the auto-ignition experiment of biomass particles was designed and conducted, indicating that the corn straw powder is more prone to spontaneous combustion, followed by rice husk and poplar wood chip, which corresponds to the results of activation energy. And the fire hazard of the biomass particles was analyzed according to the characteristic parameters. This work provides fundamental data to promote the development of storage techniques and facilitate the safe production of biomass particles.

Experimental study of fire propagation and heat transfer of biomass straw fuel with different stacked diameters and thicknesses

Investigation of heat and mass transfer characteristics during the flame propagation of biomass straw from an initial linear fire source

Self-Sustaining Smoldering Characteristics of Corn Straw Powder Stacks

Experimental and Theoretical Study on Horizontal Flame Spread Through Arrays of Wooden Dowels

Modelling of flame spread over biomass fuel arrays with various inclined angles and spacings

Mathematical modeling of combustion in a grate-fired boiler burning straw and effect of operating conditions under air- and oxygen-enriched atmospheres

Modelling the Combustion of Thermally Thick Biomass Particles

Impact of Dilution Ratio and Burning Conditions on the Number Size Distribution and Size-Dependent Mixing State of Primary Particles from Domestic Solid Fuel Burning

Thermal and kinetic analyzing of pyrolysis and combustion of self-heating biomass particles

Flame Spread and Burning Rates Through Vertical Arrays of Wooden Dowels

Comparative analysis of thermal oxidative decomposition and fire characteristics for different straw powders via thermogravimetry and cone calorimetry

Effect of firebrand size and geometry on heating from a smoldering pile under wind

Experimental Study on Fire Spread over Discrete Fuel Bed-Part II: Combined Effects of Wind and Packing Ratio

Experimental study on influence of air gap on upward flame spread over discrete fuel

Reduced Pollutant Emissions and Slagging Rate of Biomass Pellet Combustion by Optimizing the Multilayer Distribution of Secondary Air

Experimental Investigation and Theoretical Analysis of Flame Spread Dynamics over Discrete Thermally Thin Fuels with Various Inclination Angles and Gap Sizes

Experimental study on flame interaction, gas temperature distribution, and radiative heat flux from two rectangular burning propane sources

Assessment of Chopped Corn Straw Lengths for Combustion in a Fixed Bed Using a Numerical Model

STUDY OF RAPID COMBUSTION CHARACTERISTICS AND REACTION DYNAMICS OF CORN STRAW BRIQUETTE

Experimental study of flame spread behavior and heat transfer mechanism over n-butanol fuel in trays of different widths

Characterizing Dynamic Relationships Between Burning Rate and Pollutant Emission Rates in a Forced-Draft Gasifier Stove Consuming Biomass Pellet Fuels.