Abstract:Zirconia-supported tungsten oxide (WO3/ZrO2 or WZ) is known as an efficient catalyst for selective acrolein (AC) production from gas-phase dehydration of glycerol (GL). Two catalysts (WZ-CP and WZ-AN) were prepared herein using, respectively, a ZrO(OH)(2) hydrogel (ZrO(OH)(2)-CP) and its derived alcogel (ZrO(OH)(2)-AN) for a precursor of ZrO2. To optimize the reaction variables and improve the catalyst performance, the WZ-CP catalyst was employed to show the effects of (A) reaction variables (temperature, partial pressures of GL and H2O, and co-feeding H-2 or O-2); (B) catalyst modification with alkali and alkali earth metal ions (Na+, K+ and Mg2+), or transition metals (Pt, Pd, Rh and Ni). The reaction at 315 degrees C always produced the highest AC selectivity, and this temperature was then used to investigate the effects of the other variables and catalyst modifications. Increasing the molar GL/H2O ratio led to lower AC selectivity and accelerated the catalyst deactivation. Introducing 4-8 kPa O-2 to the reaction feed significantly reduced the catalyst deactivation rate but the AC selectivity was only slightly lowered. However, an addition of 4 kPa H-2 produced almost no effect on the reaction. The modified catalysts performed no better during the reaction unless the modifier was Pt or Pd, whose catalytic stabilities in the O-2-containing (4 kPa) feed were significantly higher and their selectivity for AC production slightly lowered. Working under the conditions optimized with WZ-CP, the WZ-AN catalyst offered a high AC yield (62-68%) for longer than 30 h, during which the GL conversion remained higher than 93%.

Acrolein Production from Crude Glycerol in Sub- and Super-Critical Water

Sustainable Production of Acrolein: Investigation of Solid Acid–base Catalysts for Gas-Phase Dehydration of Glycerol

Sustainable Production of Acrolein from Biodiesel-Derived Crude Glycerol over H 3 PW 12 O 40 Supported on Cs-modified SBA-15

Sustainable Production of Acrolein: Catalytic Gas-Phase Dehydration of Glycerol over Dispersed Tungsten Oxides on Alumina, Zirconia and Silica

Sustainable production of acrolein: effects of reaction variables, modifiers doping and ZrO2 origin on the performance of WO3/ZrO2 catalyst for the gas-phase dehydration of glycerol

Microwave-assisted Catalytic Dehydration of Glycerol for Sustainable Production of Acrolein over a Microwave Absorbing Catalyst

Sustainable Production of Acrolein: Acidic Binary Metal Oxide Catalysts for Gas-Phase Dehydration of Glycerol

Effects of water content on transesterification of butyl acetate in super/near-critical region

Liquid-Phase Dehydration of Glycerol to Acrolein with ZSM-5-Based Catalysts in the Presence of a Dispersing Agent

Sustainable Production Of Acrolein: Preparation And Characterization Of Zirconia-Supported 12-Tungstophosphoric Acid Catalyst For Gas-Phase Dehydration Of Glycerol

Glycerol dehydration to acrolein: Selectivity control over CsPW/Nb2O5 catalyst

Sustainable Production Of Acrolein: Gas-Phase Dehydration Of Glycerol Over 12-Tungstophosphoric Acid Supported On Zro2 And Sio2

Sustainable Production of Acrolein: Gas-phase Dehydration of Glycerol over Nb2O5 Catalyst

Dehydration of Glycerol to Acrolein over Wells–Dawson and Keggin Type Phosphotungstic Acids Supported on MCM-41 Catalysts

Solvent-Free Acetalization of Glycerol with N-Octanal Using Combined Brønsted Acid-Surfactant Catalyst

Gas Phase Dehydration of Glycerol to Acrolein over Cs2.5H0.5PW12O40/Zr-MCM-41 Catalysts Prepared by Supercritical Impregnation

Vanadium Pyrophosphate Oxides: the Role of Preparation Chemistry in Determining Renewable Acrolein Production from Glycerol Dehydration

Synergistic Effects of Nonthermal Plasma and Solid Acid Catalysts in Thermo-Catalytic Glycerol Dehydration

Progresses in Catalysts for Gas Phase Dehydration of Glycerol to Acrolein

Gas Phase Dehydration of Glycerol to Acrolein Over NaHSO4@Zr-MCM-41 Catalyst

Catalytic dehydration of glycerol to acrolein over unsupported MoP