Abstract:BackgroundMicroalgae are highly efficient cellular factories that capture CO2 and are also alternative feedstock for biofuel production. Carbohydrates, proteins, and lipids are major biochemical components in microalgae. Carbohydrates or starch in microalgae are possible substrates in yeast fermentation for biofuel production. The carbon partitioning in microalgae could be regulated through environmental stresses, such as high concentration of CO2, high light intensity, and nitrogen starvation conditions. It is essential to obtain carbohydrate-rich microalgae via an optimal bioprocess strategy.ResultsThe carbohydrate accumulation in a CO2 tolerance strain, Chlorella sp. AE10, was investigated with a two-stage process. The CO2 concentration, light intensity, and initial nitrogen concentration were changed drastically in both stages. During the first stage, it was cultivated over 3 days under 1% CO2, a photon flux of 100 μmol m−2 s−1, and 1.5 g L−1 NaNO3. It was cultivated under 10% CO2, 1000 μmol m−2 s−1, and 0.375 g L−1 NaNO3 during the second stage. In addition, two operation modes were compared. At the beginning of the second stage of mode 2, cells were diluted to 0.1 g L−1 and there was no cell dilution in mode 1. The total carbohydrate productivity of mode 2 was increased about 42% compared with that of mode 1. The highest total carbohydrate content and the highest starch content of mode 2 were 77.6% (DW) and 60.3% (DW) at day 5, respectively. The starch productivity was 0.311 g L−1 day−1 and the total carbohydrate productivity was 0.421 g L−1 day−1 in 6 days.ConclusionsIn this study, a novel two-stage process was proposed for improving carbohydrate and starch accumulation in Chlorella sp. AE10. Despite cell dilution at the beginning of the second stage, environmental stress conditions of high concentration of CO2, high light intensity, and limited nitrogen concentration at the second stage were critical for carbohydrate and starch accumulation. Although the cells were diluted, the growths were not inhibited and the carbohydrate productivity was improved. These results were helpful to establish an integrated approach from CO2 capture to biofuel production by microalgae.

Improvement of Hydrogen Yield of Lba-Transgenic Chlamydomonas Reinhardtii Caused by Increasing Respiration and Impairing Photosynthesis

Expression of the Chlamydomonas Reinhardtii Sedoheptulose-1,7-bisphosphatase in Dunaliella Bardawil Leads to Enhanced Photosynthesis and Increased Glycerol Production.

Genomic Foundation of Starch-to-Lipid Switch in Oleaginous Chlorella Spp.

Lipid Production is More Than Doubled by Manipulating a Diacylglycerol Acyltransferase in Algae

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

High-efficiency Promoter-Driven Coordinated Regulation of Multiple Metabolic Nodes Elevates Lipid Accumulation in the Model Microalga Phaeodactylum Tricornutum.

Enhanced H2 Photoproduction in Sodium Sulfite-Treated Chlamydomonas Reinhardtii by Optimizing Wavelength of Pulsed Light

Synergistic enhancement of pulsed light-induced H2 photoproduction in Chlamydomonas cells by optimal sulfite concentration and light waveform

Increasing lipid production in Chlamydomonas reinhardtii through genetic introduction for the overexpression of glyceraldehyde-3-phosphate dehydrogenase

Mutagenesis and phenotypic selection as a strategy toward domestication of Chlamydomonas reinhardtii strains for improved performance in photobioreactors

Transcriptome analysis reveals the molecular mechanism of differences in growth between photoautotrophy and heterotrophy in Chlamydomonas reinhardtii

The molecular mechanisms of Chlorella sp. responding to high CO2: A study based on comparative transcriptome analysis between strains with high- and low-CO2 tolerance

Overexpression of the Transcription Factor AtLEC1 Significantly Improved the Lipid Content of Chlorella ellipsoidea

Two non‐complementing genes encoding enzymatically active methylenetetrahydrofolate reductases control methionine requirement in fission yeast Schizosaccharomyces pombe

Improving the sunlight-to-biomass conversion efficiency in microalgal biofactories

Enhancement of β-carotene content in Chlamydomonas reinhardtii by expressing bacterium-driven lycopene β-cyclase

Using directed evolution to improve hydrogen production in chimeric hydrogenases from algal species

Development of a Microalgae-Based Continuous Starch-to-Hydrogen Conversion Approach

Hydrogen production in the Chlorella sp. DT mutants carrying heterologous electron donor ferredoxin 1 of Chlamydomonas reinhardtii

Improving carbohydrate and starch accumulation in Chlorella sp. AE10 by a novel two-stage process with cell dilution

Improvement in the Photobiological Hydrogen Production of Aggregated Chlorella by Dimethyl Sulfoxide