Abstract:Separation of liquid from concentrated slurry is a significant process in laboratory and engineering applications. In an earlier paper (X.M. Wang, S. Chang, P. Kovalsky, T.D. Waite, Multiphase flow models in quantifying constant pressure dead-end filtration and subsequent cake compression. 1. Dilute slurry filtration, J. Membr. Sci., in press), we investigated the applicability of the Smiles and Tiller multiphase flow models to description of the filtration behavior of dilute yeast slurries and here extend the analysis to consideration of concentrated slurries. Smiles' and Tiller's models are employed to quantify dynamic filtration behavior while a numerical technique derived from Smiles' method is utilized for cake compression stage characterization. The numerical method for Smiles' model for concentrated slurry filtration is the same as that for dilute slurry, while an iteration step is added to the method for Tiller's model. The results obtained indicate that the Smiles and Tiller models are equivalent in quantifying filtration behavior and cake structure of concentrated slurry and reveal that the cake structure and the ensuing filtration behavior are affected by the initial slurry solid fraction. The cake formed from slurry with a higher initial solid fraction tends to have a lower average solid fraction and a lower average specific resistance than is the case for lower initial slurry solid fractions. The variance of superficial liquid velocity through the cake during concentrated slurry filtration is much more significant than is the case during dilute slurry filtration suggesting that caution should be exercised in employing the conventional filtration model in concentrated slurry filtration data analysis. During the compression stage, the compression rate is relatively constant at the beginning then drops sharply before adopting a relatively stable value at longer times. Concomitantly, the solid compressive pressure of the upper surface of the cake increases slowly at the beginning, quickly after that and then slowly again. (c) 2007 Elsevier B.V. All rights reserved.

Accumulated Impact of Operating Conditions on the Specific Cake Resistance in Dead-End Microfiltration Mode

The Influence Of Operating Conditions On The Filtration Behavior Of Actual Extracellular Polymeric Substances (Eps) Using Dead-End Membrane Filtration Cell

A combined model for describing the trans-membrane pressure (P) variation in constant flux dead-end microfiltration (MF) process

Effect of operational conditions on membrane permeability in a coagulation-microfiltration process for water purification.

Influence of the pectin and cellulose on the performance of cross-flow microfiltration

The dynamic change of specific cake resistance in membrane bioreactor due to periodical cake relaxation

Structure and Flow Calculation of Cake Layer on Microfiltration Membranes

A surface-renewal model for constant flux cross-flow microfiltration

Effect of Operational Parameters on Sludge Accumulation on Membrane Surfaces in a Submerged Membrane Bioreactor

Role of Initially Formed Cake Layers on Limiting Membrane Fouling in Membrane Bioreactors.

Evaluation of the Importance of Various Operating and Sludge Property Parameters to the Fouling of Membrane Bioreactors.

Multiphase Flow Models In Quantifying Constant Pressure Dead-End Filtration And Subsequent Cake Compression - 2. Concentrated Slurry Filtration And Cake Compression

Identification of fouling mechanisms in MBRs at constant flowrate: model applications and SEM-EDX characterizations

Spatial variability of cake layer in membrane fouling of full-scale MBR: New insights and implications

Analysis of microfiltration performance with constant flux processing of secondary effluent

Effects of Operation Conditions, Solvent and Gelation Bath on Morphology and Performance of Ppesk Asymmetric Ultrafiltration Membrane

A study on enhancing physical cleaning effectiveness in microfiltration membrane system

The Optimized Preparation Conditions of Cellulose Triacetate Hollow Fiber Reverse Osmosis Membrane with Response Surface Methodology

Membrane Fouling Mechanism in Ultrafiltration of Succinic Acid Fermentation Broth

Echolocation and hearing in the mouse-tailed bat,Rhinopoma hardwickei: acoustic evolution of echolocation in bats

Analysis of Effect of Particles on Cake Layer Compressibility During Ultrafiltration of Upflow Biological Activated Carbon Effluent