Abstract:Livestock production systems are associated with aerial emissions of odor, volatile organic compounds (VOCs), other gases, and particular matter including airborne pathogens. Control of those emissions is needed to assure compliance with environmental regulations and long-term viability of the industry. The focus of this research is a novel approach to abatement of livestock odor and pathogens utilizing photocatalysis, i.e., UV irradiation in presence of TiO2 as a catalyst. A standard gas generation system was built and tested to generate ten odorous VOCs commonly defining livestock odors. These VOCs included methylmercaptan, ethylmercaptan, dimethylsulfide, butylmercaptan, acetic, propanoic, butyric, and isovaleric acid, p-cresol, and H2S. Our previous research established a reduction of VOCs with UV light only of 60~98% for sulfur VOCs and 91% for p-cresol, but only 20 to 45% removal for volatile fatty acids (VFAs). Titanium dioxide was used in the current research to catalyze UV reactions in the same gas mixtures of VOCs held in a small photoreactor. The reactor was designed to conduct controlled tests with UV light under dynamic (with airflows) conditions that facilitate experiments simulating exhaust from mechanically-ventilated barns. Six 10W lamps with characteristic bands at (185), 254, 312, 365 nm, respectively, and principle output at 254 nm were used as UV source in dynamic system. Solid phase microextraction (SPME) fibers were used to sample VOCs before and after UV treatment and for transfer of samples to a gas chromatography and mass spectrometry olfactometry (GC-MS-O) system. Odor analysis was completed by a forced-choice dynamic-dilution olfactometer in the Olfactometry lab at ISU. Effectiveness of four different treatment options, i.e., UV254, UV185+254, UV254+TiO2, and UV185+254+TiO2 was assessed. Effect of light energy, catalyst presence and light wavelength was evaluated. More than 50% in chemical reduction was found for all VOCs tested with a treatment time of 18.5 second. A linearly positive correlation was found between the percent conversion of tested VOCs and light energy dose. TiO2 showed to greatly improve the treatment effectiveness on VOCs, VFAs in particular, no matter deep UV was used or not. However, when TiO2 was used, deep UV showed very little improvement in degrading VOCs tested, while significant improvement was observed when no TiO2 was used. Total odor reduction of 70% by certain energy level indicated the feasibility of odor mitigation by UV light. Continued work includes simultaneous inactivation of airborne pathogens with UV light.

Characterisation of photocatalytic degradation of odorous compounds associated with livestock facilities by means of PTR-MS

Review on Photocatalytic Applications for Deodorization in Livestock and Poultry Farms

Real-time quantification of emissions of volatile organic compounds from land spreading of pig slurry measured by PTR-MS and wind tunnels

VOC Removal from Manure Gaseous Emissions with UV Photolysis and UV-TiO2 Photocatalysis

Application of PTR-MS for measuring odorant emissions from soil application of manure slurry

Treatment of Livestock Odor and Pathogens with Ultraviolet Light

Evaluation of TiO2 Based Photocatalytic Treatment of Odor and Gaseous Emissions from Swine Manure with UV-A and UV-C

Characterization of odorous industrial plumes by coupling fast and slow mass spectrometry techniques for volatile organic compounds

Photocatalytic Oxidation of Volatile Organic Compounds Using Fluorescent Visible Light

An Efficient Process for Aromatic Vocs Degradation: Combination of Vuv Photolysis and Photocatalytic Oxidation in a Wet Scrubber

The Emission Patterns of Volatile Organic Compounds During Aerobic Biotreatment of Municipal Solid Waste Using Continuous and Intermittent Aeration

Abatement of VOCs Mixture of Emerging Concern by VUV-PCO Process: from Lab to Pilot Scale.

An Insight Of Ptr-Ms-Based Measurement Of Large Vocs

Characterization of Odorous Charge and Photochemical Reactivity of VOC Emissions from a Full-Scale Food Waste Treatment Plant in China

Application of a Self-Developed Proton Transfer Reaction-Mass Spectrometer to On-Line Monitoring Trace Volatile Organic Compounds in Ambient Air

A model for analyzing the performance of photocatalytic air cleaner in removing volatile organic compounds

Determination and Risk Assessment of By-Products Resulting from Photocatalytic Oxidation of Toluene

Performance characteristics and applications of a proton transfer reaction-mass spectrometer for measuring volatile organic compounds in ambient air.

Photocatalytic Oxidation for Indoor Air Purification: a Literature Review

Near real-time quantification of microbial volatile organic compounds from mycoparasitic fungi: Potential for advanced monitoring and pest control

Pilot-Scale Testing of UV-A Light Treatment for Mitigation of NH3, H2S, GHGs, VOCs, Odor, and O3 Inside the Poultry Barn