Abstract:Zirconia-supported tungsten oxide (WO3/ZrO2 or WZ) is known as an efficient catalyst for selective acrolein (AC) production from gas-phase dehydration of glycerol (GL). Two catalysts (WZ-CP and WZ-AN) were prepared herein using, respectively, a ZrO(OH)(2) hydrogel (ZrO(OH)(2)-CP) and its derived alcogel (ZrO(OH)(2)-AN) for a precursor of ZrO2. To optimize the reaction variables and improve the catalyst performance, the WZ-CP catalyst was employed to show the effects of (A) reaction variables (temperature, partial pressures of GL and H2O, and co-feeding H-2 or O-2); (B) catalyst modification with alkali and alkali earth metal ions (Na+, K+ and Mg2+), or transition metals (Pt, Pd, Rh and Ni). The reaction at 315 degrees C always produced the highest AC selectivity, and this temperature was then used to investigate the effects of the other variables and catalyst modifications. Increasing the molar GL/H2O ratio led to lower AC selectivity and accelerated the catalyst deactivation. Introducing 4-8 kPa O-2 to the reaction feed significantly reduced the catalyst deactivation rate but the AC selectivity was only slightly lowered. However, an addition of 4 kPa H-2 produced almost no effect on the reaction. The modified catalysts performed no better during the reaction unless the modifier was Pt or Pd, whose catalytic stabilities in the O-2-containing (4 kPa) feed were significantly higher and their selectivity for AC production slightly lowered. Working under the conditions optimized with WZ-CP, the WZ-AN catalyst offered a high AC yield (62-68%) for longer than 30 h, during which the GL conversion remained higher than 93%.

Highly Efficient Production of Acrylic Acid by Sequential Dehydration and Oxidation of Glycerol

Microwave-assisted Catalytic Dehydration of Glycerol for Sustainable Production of Acrolein over a Microwave Absorbing Catalyst

Highly Efficient Process for the Conversion of Glycerol to Acrylic Acid via Gas Phase Catalytic Oxidation of an Allyl Alcohol Intermediate

Oxidative Dehydration of Glycerol to Acrylic Acid over Vanadium-Substituted Cesium Salts of Keggin-Type Heteropolyacids

Renewable Production of Acrylic Acid and Its Derivative: New Insights into the Aldol Condensation Route over the Vanadium Phosphorus Oxides

Glycerol dehydration to acrolein: Selectivity control over CsPW/Nb2O5 catalyst

Vanadium Pyrophosphate Oxides: the Role of Preparation Chemistry in Determining Renewable Acrolein Production from Glycerol Dehydration

Highly Selective and Stable CsPW/Nb2O5 Catalysts for Dehydration of Glycerol to Acrolein

Sustainable Production Of Acrolein: Preparation And Characterization Of Zirconia-Supported 12-Tungstophosphoric Acid Catalyst For Gas-Phase Dehydration Of Glycerol

Sustainable Production of Acrolein: Investigation of Solid Acid–base Catalysts for Gas-Phase Dehydration of Glycerol

Sustainable production of acrolein: effects of reaction variables, modifiers doping and ZrO2 origin on the performance of WO3/ZrO2 catalyst for the gas-phase dehydration of glycerol

Sustainable Production of Acrolein: Acidic Binary Metal Oxide Catalysts for Gas-Phase Dehydration of Glycerol

Sustainable Production of Acrolein: Catalytic Gas-Phase Dehydration of Glycerol over Dispersed Tungsten Oxides on Alumina, Zirconia and Silica

Solvent-Free Acetalization of Glycerol with N-Octanal Using Combined Brønsted Acid-Surfactant Catalyst

WVOx Supported on Industrial Al2O3, SiO2, AC, TiO2–Al2O3 for Catalytic Dehydration of Gas-Glycerol to Acrolein

Sustainable Production Of Acrolein: Gas-Phase Dehydration Of Glycerol Over 12-Tungstophosphoric Acid Supported On Zro2 And Sio2

Gas Phase Dehydration of Glycerol to Acrolein Over NaHSO4@Zr-MCM-41 Catalyst

Acetalization of Carbonyl Compounds with 2,2,4-Trimethyl-1,3-pentanedio Catalyzed by Novel Carbon Based Solid Acid Catalyst

High Efficient Acetalization of Carbonyl Compounds with Diols Catalyzed by Novel Carbon-Based Solid Strong Acid Catalyst

Selective Oxidation of Glycerol in a Base-Free Aqueous Solution: A Short Review

Dehydration of Glycerol to Acrolein over Wells–Dawson and Keggin Type Phosphotungstic Acids Supported on MCM-41 Catalysts