Abstract:A pressurized chemical-looping combustion combined cycle (PCLC) system is proposed for solid fuels combustion with potential high system efficiency, improving the fuel conversion and lowering the cost for CO, sequestration. In this Study pressurized CLC of coal With Companhia Valedo Rio Doce (CVRD) iron Ore was investigated in a laboratory fixed bed reactor focusing on cyclic performance lice. CVRD iron Ore particles were exposed alternately for 20 cycles to reduction by 0.4 g of Chinese Xuzhou bituminous coal gasified with 87% stream/N-2 mixture and oxidation with 5% O-2 in N-2 at 970 degrees C at atmospheric pressure (0.1 MPa) and a typical elevated pressure of 0.5 MPa. With increasing number of redox cycles, more pyrolysis gases are oxidized by the oxygen carrier. At elevated pressure, the chat gasification is intensified with negligible gasification intermediate products released. The CO2 fraction increases from 80% to approximate 90% after 10 cycles at atmospheric pressure. At elevated pressures, the average CO2 fraction stabilizes at 95.75%, approximate to the equilibrium value. The carbon conversion at 0.1 MPa and 0.5 MPa is 76.48 and 84.65%, respectively, and maintains approximately the same during the cycles because excessive Steam gasification agent used in this study. The oxygen carrier conversion determined from the oxygen in ass balance verifies that reduction level increases With the Cycle number. The physical and chemical properties of oxygen carrier particles were characterized. X-ray diffraction (XRD) analysis verifies the extent of reduction level increases with cycles, No detectable formation of compound of iron oxide and coal ash was observed. Scanning electron microscope (SEM) analyses show that the iron Ore particles become porous and that more pores formed with cycles. Agglomeration of particles was not observed in all experiments at both pressures. X-ray spectroscopy (EDX) analysis show an increasing amount of coal ash Oil the Oxygen carrier particles With increasing numbers of cycles. Pore size analyses Show that the oxygen carrier particles maintained mesopores for both atmospheric and elevated pressure. The increase of both surface area and pore volume illustrates that the particles become more porous with redox cycles. This study Show that pressurized CLC of coal is promising and a low-cost iron ore-based oxygen carrier may be suitable for pressurized CLC of coal.

Coal Char-fueled Chemical Looping Combustion Use Different Iron-Based Oxygen Carriers

Reduction Rate Enhancements for Coal Direct Chemical Looping Combustion with an Iron Oxide Oxygen Carrier

Use of Fe2O3-Containing Industrial Wastes As the Oxygen Carrier for Chemical-Looping Combustion of Coal: Effects of Pressure and Cycles

Chemical Looping Combustion Characteristics of Coal with Fe2O3 Oxygen Carrier

Pressurized chemical-looping combustion of coal using an iron ore as oxygen carrier in a pilot-scale unit

Interaction Between Iron-Based Oxygen Carrier and Four Coal Ashes During Chemical Looping Combustion

Inert supports enhanced sulphur-resistant of iron-based oxygen carriers in chemical looping combustion of element sulphur

Interaction Between Fe-based Oxygen Carriers and N-Heptane During Chemical Looping Combustion

Experiments on chemical looping combustion of coal with a NiO based oxygen carrier

Evaluation of Fe-Ni Composite Oxygen Carrier in Coal Chemical Looping Gasification

Performance and Kinetics of Iron-Based Oxygen Carriers Reduced by Carbon Monoxide for Chemical Looping Combustion

Research and Development of Coal-fueled Chemical Looping Combustion

Comparison of a new micaceous iron oxide and ilmenite as oxygen carrier for Chemical looping combustion with respect to syngas conversion

Barium Aluminate Improved Iron Ore for the Chemical Looping Combustion of Syngas

Chemical Looping Combustion Characteristics of Coal with a Novel CaSO4–Ca2CuO3 Mixed Oxygen Carrier

The use of iron oxide as oxygen carrier in a chemical-looping reactor

Pressurized Chemical-Looping Combustion of Chinese Bituminous Coal: Cyclic Performance and Characterization of Iron Ore-Based Oxygen Carrier

Chemical Looping Combustion-Adsorption Of Hcl-Containing Syngas Using Alkaline-Earth Coated Iron Ore Composites For Simultaneous Purification And Combustion Enhancement

Reactivity investigation on chemical looping gasification of coal with Iron-Manganese based oxygen carrier

Pressurized chemical-looping combustion of coal with an iron ore-based oxygen carrier