Abstract:Hydropower has been the leading renewable source and cheapest ways to generate electrical energy in the world. In recent years, there has been a major upsurge in the hydropower development because of the use of pump as turbine (PAT). However, the operational reliability of a PAT is greatly affected by the unsteady flow fields; therefore, it is important to examine the unsteady flow behavior which can be used as a reference to reduce the noise, vibration, and cavitation performance for centrifugal pumps working as turbines. Thus, the objective of this study was to evaluate the unsteady flow fields by analyzing the distribution of the pressure pulsations using both numerical and experimental measurements in a PAT operating in pump mode. Firstly, the three‐dimensional (3D) unsteady flow equations were solved using SST <i>k‐</i>ω turbulence model during the numerical calculations. Secondly, the numerical results of the hydraulic pump performance were validated by the experimental measurements for numerical accuracy. Lastly, pressure transducers are positioned at certain monitoring points to measure the pressure in the PAT investigated. The numerical and experimental results show that the main frequency of the pressure pulsation is equal to the blade frequency, and as it deviates from the design operating condition, the magnitude of pressure pulsation intensifies. Furthermore, the impeller eye marked the lowest pressure coefficients especially at the design condition and makes it highly susceptible to cavitation. High pressure coefficients were obviously seen at the pressure side on the blade surface closer to the trailing edge at all studied operating conditions. Meanwhile, the rotor‐stator interaction generated the highest pressure pulsation distribution at the volute tongue. Thus, modification of the volute tongue is an optimal approach of reducing the pressure pulsation intensity in the volute and pump as a whole.

Numerical Prediction of the Pressure Fluctuations on Small Discharge Condition of A Pump-Turbine at Pump Mode

Pressure pulsation analysis of runner and draft tube of pump turbine under different working conditions

Pressure pulsation in small opening operating mode of pump turbine’s turbine mode

Experimental and numerical investigations on pressure pulsation in a pump mode operation of a pump as turbine

Distribution Features of Flow Patterns and Pressure Pulsations of Pump-Turbine in Five Operating Modes on the Four-Quadrant Plane

Numerical Predictions of Pressure Fluctuations in a Model Pump Turbine with Small Guide Vane Opening based on Partial Averaged Navier Stokes Approach

Unsteady Flow Analysis of Pump Mode Small Discharge Condition for a Francis Pump-turbine

Pressure Fluctuation Propagation of a Pump Turbine at Pump Mode under Low Head Condition

Experimental Study of the Pressure Fluctuations in A Pump Turbine at Large Partial Flow Conditions

Analysis of Pressure Fluctuations in a Prototype Pump-Turbine with Different Numbers of Runner Blades in Turbine Mode

Numerical Study of Pressure Fluctuations in Different Guide Vanes' Opening Angle in Pump Mode of a Pump Turbine

Analysis of Pressure Fluctuation of a Pump-Turbine with Splitter Blades on Small Opening in Turbine Mode

Pressure fluctuation prediction of a model kaplan turbine by unsteady turbulent flow simulation

Numerical Simulation of Flow Characteristics of Pump Turbine with Small Guide Vanes Opening

Pressure fluctuation characteristics of pump-turbine at pump mode

Prediction of Pressure Fluctuation by Turbulent Flow Analysis

Analysis of the Flow Behavior and Pressure Fluctuation of a Pump Turbine with Splitter Blades in Part-Load Pump Mode

Numerical Study of Pressure Fluctuations Transfer Law in Different Flow Rate of Turbine Mode in A Prototype Pump Turbine

Numerical simulation of excess output condition of a pump-turbine based on compressible calculation

Numerical simulation of the unstable flow phenomenon in a pump turbine at the load rejection conditions in turbine mode

Investigations on Pressure Fluctuations in the S-Shaped Region of a Pump–Turbine