Abstract:The semi-cylindrical foot end of a legged robot is suitable for the robot movements in complex environments and is the most commonly used foot end type. However, its actual contact point will deviate from the ideal contact point when it touches the ground to support the robot or when it slips due to its specific structure, resulting in trajectory deviation. To solve this deviation problem between the actual and desired contact positions of the robot foot end, this study proposes a novel kinematics correction strategy for a legged robot with a semi-cylindrical foot end based on a virtual degree of freedom (V-DOF). Two sampling systems are studied as follows. First, the forward and inverse kinematic solutions are derived when the foot end is regarded as a point; then, the root joint trajectory deviation of the robot’s leg is analyzed, and the deviation value of the foot end in motion is obtained when the robot body is at different angles with the contact surface. Further, considering the tangential relationship between the semi-cylindrical foot end and the contact surface, the foot end is considered as a rod that is always perpendicular to the contact surface. Thus, a semi-cylindrical foot end correction strategy based on V-DOF is established. In addition, the deviation curves when the foot end slips are derived, and it is theoretically proven that the correction algorithm also applies to the slipping of the foot end. Finally, a co-simulation model and an experimental platform of the leg hydraulic drive system (LHDS) are used for simulation and experimental verification. The results indicate that the proposed strategy can effectively reduce the root joint trajectory deviation when the legged robot body is at different angles with the contact surface or when the foot end is slipping. The above research results can provide important reference and experimental basis for the legged-motion control with any DOF equipped with such a type of foot end.

Solving Position-Posture Deviation Problem of Multi-Legged Walking Robots with Semi-Round Rigid Feet by Closed-Loop Control

Standing Posture Control of Bipedal Robots with Adaptive Compliance under Unknown Payload Variations and External Disturbances

Feedback Control of Planar Biped Robot with Regulable Step Length and Walking Speed

Stable walking of 3D compass-like biped robot with underactuated ankles using discrete transverse linearization

Stable walking control and strategy of under-actuated biped robot

Modeling and Adaptive Robust Posture Control of 3-Rps Pneumatic Parallel Platform

Coupling Mechanical Design and Control Design for Energy-Efficient and Stable Walking of A Compass-Like Biped

Kinematics correction algorithm for the LHDS of a legged robot with semi-cylindrical foot end based on V-DOF

Posture Stabilization Control for a Quadruped Robot Walking on Swaying Platforms.

Non-linear Sliding Mode Control of the Lower Extremity Exoskeleton Based on Human–robot Cooperation

Nonsingular Fast Terminal Sliding Mode Posture Control for Six-Legged Walking Robots with Redundant Actuation

A novel kinematics and statics correction algorithm of semi-cylindrical foot end structure for 3-DOF LHDS of legged robots

Design and Control of a Multi-Locomotion Parallel-Legged Bipedal Robot

Active suspension control with consensus strategy for dynamic posture tracking of wheel-legged robotic systems on uneven surfaces

Accurate and Robust Body Position Trajectory Tracking of Six-Legged Walking Robots with Nonsingular Terminal Sliding Mode Control Method

Quasi Open-loop Control for Semi-passive Biped Robots

Global Posture Stabilization for the Kinematic Model of a Rear-Axle Driven Car-Like Mobile Robot Considering Obstacle Avoidance

Stabilizing Control of Humanoids' Walking Based on AHRS Feedback

Biped Walking Based on Stiffness Optimization and Hierarchical Quadratic Programming

Global-Position Tracking Control of 3-D Bipedal Walking via Virtual Constraint Design and Multiple Lyapunov Analysis

Nonlinear model predictive control for robust bipedal locomotion: exploring angular momentum and CoM height changes