Simultaneous Enhancement of Microalgae Biomass Growth and Lipid Accumulation under Continuous Aeration with 15% CO2

Yun Huang,Jun Cheng,Hongxiang Lu,Rui Huang,Junhu Zhou,Kefa Cen

DOI: https://doi.org/10.1039/c5ra08401f

IF: 4.036

2015-01-01

RSC Advances

Abstract:Continuous aeration with 15% CO2 induced nitrogen deprivation during Chlorella PY-ZU1 cultivation, thus simultaneously promoting biomass (2.78 g L−1) and lipid (47.04%) production.

What problem does this paper attempt to address?

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Huan Lin,Chen Fang,Zhang Li,Hua Cheng,Lin Zhang

2011-01-01

Abstract:Recent soaring oil prices and diminishing world oil reserves, coupled with the increased emission of greenhouse gases and the predicted threat of climate change, have generated renewed interest in using algae as an alternative and renewable feedstock for energy production. Aimed at intensifying microalgal CO2 fixation and lipid production enhancement, membrane contactors have been applied to capture CO2 from air, enhance microalgal cultivation and extract lipid from algae. In order to capture CO2 from air, three kinds of membrane contactors with absorption agents, Carbonic Anhydrase (CA)-hydrogel and ionic liquid, were designed. The photo-bioreactor integrated with a hollow-fiber membrane module to supply CO2 has been designed for Chlorella vulgaris cultivation. Using a membrane contactor, the residence time of CO2 in the photo-bioreactor can be prolonged to enhance CO2 biofixation. The biofixation rate has reached 0.38 g/(L·h), which is more than 2-3 times those in conventional reactors. In order to increase lipid productivity, the effects of cultivation conditions, including KNO3-level, CO2 concentration and irradiance, on the cell growth, chlorophyll content and lipid accumulation of Chlorella vulgaris are systematically investigated. The lipid productivity has reached 40 mg/(L·d) under select cultivated conditions, which is more than 2.5-fold of that reported. Finally, to simplify the algal lipid production process and thus to reduce costs, microalgal lipid extracted in situ and continuously produced in the bioreactor integrated with membrane-based extraction has been investigated in this study.
Enhanced Lipid Productivity of Chlorella Pyrenoidosa Through the Culture Strategy of Semi-Continuous Cultivation with Nitrogen Limitation and Ph Control by Co2

Feifei Han,Jianke Huang,Yuanguang Li,Weiliang Wang,Minxi Wan,Guomin Shen,Jun Wang

DOI: https://doi.org/10.1016/j.biortech.2013.03.017

IF: 11.4

2013-01-01

Bioresource Technology

Abstract:Microalgae cultivation with high lipid productivity has received much attention in recent years owing to the economic potential of biofuels production and CO2 emission reduction. Previous studies had reported that the ways of pH-regulation, nutrition-limitation and semi-continuous culture mode can either increase the cells growth rate or promote lipid accumulation. In this study, the novel culture strategy of integrating both nutrition limitation and pH-regulation by CO2 in a semi-continuous cultivation was investigated for enhancing the lipid productivity. In the batch culture, the best growth performance was achieved by controlling pH at 7; lipid contents of the cells can be increased under the nitrogen-limitation conditions. The maximum lipid productivity of 115 mg L-1 d(-1) was achieved in the novel culture strategy of semi-continuous cultivation with nitrogen-limitation and pH-regulation by CO2, which was 3.64-fold higher than that in the batch culture without pH control and nitrogen limitation. (C) 2013 Elsevier Ltd. All rights reserved.
Enhancing Lipid Production in Microalgae Chlorella PY-ZU1 with Phosphorus Excess and Nitrogen Starvation under 15% CO2 in a Continuous Two-Step Cultivation Process

Feifei Chu,Jun Cheng,Xiangdong Zhang,Qing Ye,Junhu Zhou

DOI: https://doi.org/10.1016/j.cej.2019.121912

IF: 15.1

2019-01-01

Chemical Engineering Journal

Abstract:To promote biomass and lipid productivity of microalgae in a continuous two-stage cultivation process with 15% CO2, adequate phosphorus was supplemented in the second stage of cultivation involving nitrogen starvation and stored with regulated existence patterns to improve the metabolic activity of Chlorella PY-ZU1. The results showed that the applied strategy allowed microalgae biomass concentration and lipid productivity 1.3 and 2.2 times higher, respectively, than those without phosphorus supplementation. Chlorella PY-ZU1 cells cultivated with an adequate amount of phosphorus were analyzed by electron microscopy that revealed the distribution of polyphosphates in the cytoplasm, vacuoles, and along the cell membranes. P-31 nuclear magnetic resonance (P-31 NMR) showed polyphosphate, pyrophosphate, and orthophosphate contents of 0.59, 2.46, and 8.21 mg g(-1), respectively, in the extracts of Chlorella PY-ZU1 cells obtained by the NaOH-EDTA method. Moreover, the ATP synthase involved in the photosynthesis and oxidative phosphorylation pathways was up-regulated to promote biomass productivity, while the enzymes involved in carbon fixation and glycerolipid metabolism were up-regulated to facilitate lipid accumulation in cells.
Effect of CO₂ supply conditions on lipid production of Chlorella vulgaris from enzymatic hydrolysates of lipid-extracted microalgal biomass residues.

Hongli Zheng,Zhen Gao,Fengwei Yin,Xiaojun Ji,He Huang

DOI: https://doi.org/10.1016/j.biortech.2012.09.048

IF: 11.4

2012-01-01

Bioresource Technology

Abstract:The hydrolysates from lipid-extracted microalgal biomass residues (LMBRs) were used as a source of nutrients for the cultivation of Chlorella vulgaris for lipid production under various CO2 supply conditions, including different CO2 concentrations and aeration rates. Both parameters had a significant effect on lipid production. A CO2 concentration of 5% was found to be most suitable for microalgal growth. Microalga grew best at a CO2 aeration rate of 0.5 vvm. At this rate, biomass concentration and lipid productivity were at a maximum of 3.83 g L-1 and 157 mg L-1 d(-1), respectively, but decreased at lower or higher aeration rates. The present results showed that LMBRs utilization was effective in microalgal lipid production under suitable CO2 supply conditions. Crown Copyright (C) 2012 Published by Elsevier Ltd. All rights reserved.
Revealing Mechanism and Influence of Microalgae Cells' Periodical Auto-Agglomeration Induced by High Concentration of Carbon Dioxide

Hongyan Peng,Yun Huang,Ao Xia,Xianqing Zhu,Xun Zhu,Qiang Liao

DOI: https://doi.org/10.1016/j.biortech.2023.129120

IF: 11.4

2023-01-01

Bioresource Technology

Abstract:The efficient cultivation of microalgae using CO2 from flue gas can be a win-win situation for both environmental protection and energy accessibility. In general, 10-20% of CO2 in flue gas would decrease pH and inhibit microalgae growth. However, Chlorella sorokiniana MB-1 under 15% CO2 showed a periodical auto -agglomeration, which promoted microalgae growth on the contrary in this study. The maximum biomass con-centration of 3.27 g L-1 was higher than that cultivated with an optimal CO2 concentration. The pH decreased to 6.04 after the mixed gas with 15% CO2 (v/v) was bubbled into medium for 0.5 h, which resulted in auto -agglomeration to protect microalgae from acidification and keep a high specific growth rate of 0.03 h(-1). Then the pH recovered to 7 during stabilization phase, auto-agglomeration ratio was up to 100% because of lamellar extracellular polymeric substances. Therefore, the interesting periodical agglomeration both enhanced growth and simplified harvesting.
Enhanced lipid accumulation of photoautotrophic microalgae by high-dose CO2 mimics a heterotrophic characterization

Zhilan Sun,Xiao Dou,Jun Wu,Bing He,Yuancong Wang,Yi-Feng Chen

DOI: https://doi.org/10.1007/s11274-015-1963-6

Abstract:Microalgae possess higher photosynthetic efficiency and accumulate more neutral lipids when supplied with high-dose CO2. However, the nature of lipid accumulation under conditions of elevated CO2 has not been fully elucidated so far. We now revealed that the enhanced lipid accumulation of Chlorella in high-dose CO2 was as efficient as under heterotrophic conditions and this may be attributed to the driving of enlarged carbon source. Both photoautotrophic and heterotrophic cultures were established by using Chlorella sorokiniana CS-1. A series of changes in the carbon fixation, lipid accumulation, energy conversion, and carbon-lipid conversion under high-dose CO2 (1-10%) treatment were characterized subsequently. The daily carbon fixation rate of C. sorokiniana LS-2 in 10% CO2 aeration was significantly increased compared with air CO2. Correspondingly, double oil content (28%) was observed in 10% CO2 aeration, close to 32.3% produced under heterotrophic conditions. In addition, with 10% CO2 aeration, the overall energy yield (Ψ) in Chlorella reached 12.4 from 7.3% (with air aeration) because of the enhanced daily carbon fixation rates. This treatment also improved the energetic lipid yield (Ylipid/Es) with 4.7-fold, tending to the heterotrophic parameters. More significantly, 2.2 times of carbon-lipid conversion efficiency (ηClipid/Ctotal, 42.4%) was observed in 10% CO2 aeration, towards to 53.7% in heterotrophic cultures, suggesting that more fixed carbon might flow into lipid synthesis under both 10% CO2 aeration and heterotrophic conditions. Taken together, all our evidence showed that 10% CO2 may push photoautotrophic Chlorella to display heterotrophic-like efficiency at least in lipid production. It might bring us an efficient model of lipid production based on microalgal cells with high-dose CO2, which is essential to sustain biodiesel production at large scales.
Unraveling non-linear dynamics of biomass, photosynthesis efficiency, and lipid accumulation in Chlorella vulgaris under mixotrophic cultivation

Zhuang Li,Ting Yuan,Jinjin Zhao,Canmei Wang,Qun Wei,Xiangmeng Ma,Gairen Yang

DOI: https://doi.org/10.1016/j.jclepro.2024.141692

IF: 11.1

2024-03-13

Journal of Cleaner Production

Abstract:In recent years, the potential of microalgae-based biofuels as a renewable energy source has garnered significant attention due to their inherent ability to sequester carbon dioxide (CO 2 ) efficiently. This study investigates Chlorella vulgaris FACHB-8 's growth, photosynthesis, and lipid accumulation under different carbon source and CO 2 concentration conditions with Central composite design. Results reveal that a 10% CO 2 concentration enhances biomass and cell count, yielding 0.94 g L −1 and 106.8 × 10 6 cells·ml −1 , respectively, after 14 days of autotrophic cultivation. However, excessive CO 2 inhibits growth, notably observed with 20% CO 2 yielding 0.86 g L −1 biomass. Pigment content positively correlates with biomass under autotrophic conditions, reaching 42.55 mg g −1 in the 10% CO 2 group. Under photosynthetic mixotrophy, carbonic anhydrase activity decreases with higher CO 2 concentrations, suggesting reduced enzyme demand. Glucose exhibits the highest lipid content (31.87%), surpassing autotrophic conditions (24.80%). Glycerol presents favorable lipid content (31.78%) and settling efficiency (85.07%), indicating potential for self-flocculation harvesting. Chlorophyll fluorescence data highlight active photosynthesis in mixotrophic conditions, with glucose and sucrose affecting energy conversion. This highlights the critical role of microalgae biofuels in the pursuit of cleaner and more sustainable energy solutions.

environmental sciences,green & sustainable science & technology,engineering, environmental
Regulation of carbon metabolic fluxes in response to CO 2 supplementation in phototrophic Chlorella vulgaris : a cytomic and biochemical study

Huifeng Peng,Dong Wei,Feng Chen,Gu Chen

DOI: https://doi.org/10.1007/s10811-015-0542-4

2015-01-01

Journal of Applied Phycology

Abstract:As one of the promising species of microalgae for biofuel production, Chlorella vulgaris CS-42 was cultivated phototrophically in two cylindrical photobioreactors with aeration of 5 % ( v / v ) CO 2 or air for 13 days to evaluate the effects of CO 2 supplementation on biomass, CO 2 fixation performance, and biochemical content. Significant increases of specific growth rate and total carbon content in biomass resulting in a higher CO 2 fixation rate were found with 5 % CO 2 . The maximum biomass concentration, carbohydrate and fatty acid contents with 5 % CO 2 were significantly higher than those with air, while carbohydrate biosynthesis was most affected as compared to other biochemical components. Cytomic analysis revealed a rapid accumulation of neutral lipid in the late growth phase with more lipid bodies visualized by confocal laser scanning microscopy (CLSM), when nitrate consumption was accelerated with CO 2 supplementation. Gas chromatography mass spectrometry (GC-MS) analysis indicated that 5 % CO 2 favored the formation of C18:2, which led to a decrease in the degree of lipid unsaturation (DLU). These results proved that CO 2 supplementation was one of the most efficient methods to significantly prompt the growth of microalgae and increase the C/N ratio in the medium, which in turn regulated the carbon metabolic flux to enhance neutral lipid and fatty acid production in C. vulgaris .
Enhancing Microalgae Growth and Product Accumulation with Carbon Source Regulation: New Perspective for the Coordination Between Photosynthesis and Aerobic Respiration.

Pengtao Gao,Liang Guo,Yangguo Zhao,Chunji Jin,Zonglian She,Mengchun Gao

DOI: https://doi.org/10.1016/j.chemosphere.2021.130435

IF: 8.8

2021-01-01

Chemosphere

Abstract:The coordination between photosynthesis and aerobic respiration under mixotrophic cultivation can make a difference to the growth and biochemical composition of microalgae. However, the response of carbon metabolism to carbon source composition under mixotrophic microalgae cultivation has not been well studied. In this study, the synergistic effects of inorganic carbon (IC) and organic carbon (OC) supply on the growth and carbon metabolism of Chlorella vulgaris under mixotrophic cultivation were investigated. The increase of the proportion of HCO3− had a positive effect on the expression of ribulose-1,5-bisphosphate carboxylase/oxygenase (RuBisCO), which promoted the biomass production and carbon fixing. The activity of citrate synthase was attenuated with the increase of IC/OC ratio, indicating that the energy needed for the biomass production in groups with high IC/OC ratio was contributed by photoreaction. Biochemical analysis showed that CO32− was more efficient than HCO3− for carbohydrate and lipid accumulation of Chlorella vulgaris, and the highest amount of carbohydrate (30.2%) and lipid (35.8%) was recorded with the combined use of CO32− and glucose. The results could provide a new perspective on carbon metabolism and enzyme regulation in mixotrophic microalgae cultivation.
Biomass Producing and CO2 Capturing Simultaneously by Chlorella Vulgaris: Effect of CO2 Concentration and Aeration Rate

Xuan Wei,Guiyuan Yu,Wen Cao,Min Feng,Yutong Xu,Mingjie Jin,Yuxia Zhang,Tengteng Li,Liejin Guo

DOI: https://doi.org/10.1016/j.energy.2024.132321

IF: 9

2024-01-01

Energy

Abstract:Optimizing the operational parameters of the photosynthetic process is essential for effective microalgae-based CO2 2 capture and fixation. This study develops and validates models that can relate the effects of CO2 2 concentration and aeration rate on relevant microalgal properties, including biomass productivity and CO2 2 biofixation rate. The maximum biomass concentration was predicted as 2.80 g & sdot;L-1- 1 at the optimal CO2 2 concentration of 10.2 % and aeration rate of 0.55 vvm. Based on the proposed models, the CO2 2 biofixation rate characterized by carbon content in dry microalgal cells, and the timings of microalgae entering the exponential growth and stationary growth phases were effectively predicted. Furthermore, the lower heating value of harvested microalgal biomass was up to 21.98 kJ & sdot;g-- 1 and the dominant fatty acid methyl esters (FAME) species were C16 - C18, highlighting the potential of Chlorella vulgaris as the feedstock for microalgae-based energy production. Consequently, microalgae present a remarkable dual function for CO2 2 mitigation and renewable bioenergy production.
Influence of Exogenous CO2 on Biomass and Lipid Accumulation of Microalgae Auxenochlorella Protothecoides Cultivated in Concentrated Municipal Wastewater

Bing Hu,Min,Wenguang Zhou,Yecong Li,Michael Mohr,Yanling Cheng,Hanwu Lei,Yuhuan Liu,Xiangyang Lin,Paul Chen,Roger Ruan

DOI: https://doi.org/10.1007/s12010-012-9566-2

2012-01-01

Applied Biochemistry and Biotechnology

Abstract:The effects of exogenous CO2 on the growth and lipid accumulation of a local screened facultative heterotrophic microalgae strain Auxenochlorella protothecoides (UMN280) as well as nutrient removal from concentrated municipal wastewater stream (centrate) were examined in this study. A 12-day batch experiment was conducted with CO2 aeration at three levels, namely, 0%, 1%, and 5% (v/v) CO2 mixed with air, under light intensity of 60 μmol/(m2 @@s). A two-stage growth pattern was observed. The first stage (first–fifth day) was dominated by heterotrophic growth in which organic carbon was the main carbon source. The second stage (6th–12th day) was dominated by autotrophic growth in which exogenous CO2 had a positive effect on algal biomass accumulation. The addition of 5% CO2 was better than that of 1% CO2 on the biomass and lipid production. The uptakes of nutrients were similar between injection and no injection of CO2, except on phosphorus removal which was affected by the acidification of CO2.
High Concentration Co2 Sequestration by Using Microalgae in Staged Cultivation

Guanhua Huang,Tao Li,Feng Chen,Huan He,YaLi Kuang

DOI: https://doi.org/10.1002/ep.12420

IF: 2.824

2016-01-01

Environmental Progress & Sustainable Energy

Abstract:The acclimated fresh water microalga Chlorella vulgaris has the excellent growing capability in the process of staged cultivation (SC). In this study, the alga solutions with low (106/mL) and high (107/m) cell densities showed different abilities of growth with different levels of CO2–air mixture gases[5%, 10%, 15% (v/v)]. The SC process can improve the algal mass productivity rapidly by the aerating increased concentrations of CO2 of mixed gases into the algae solution in a short time. The results showed that the cell density was improved to 1.72 g L−1 within 7 days, showing 3.1, 1.48, and 1.70 times improvement compared to that in the biomass from the culture with separate 5, 10, and 15% CO2–air mixture gases. Besides, there were not the obvious distinctions on the contents of biochemicals (carbohydrate, protein, and lipid) from these algae. This study proved that SC process was an efficient method to improve biomass productivity of Chlorella sp. in a short time with low initial cell density. © 2016 American Institute of Chemical Engineers Environ Prog, 35: 1862–1867, 2016
Optimizing Culture Conditions for Heterotrophic-Assisted Photoautotrophic Biofilm Growth of Chlorella Vulgaris to Simultaneously Improve Microalgae Biomass and Lipid Productivity

Yangli Ye,Yun Huang,Ao Xia,Qian Fu,Qiang Liao,Weida Zeng,Yaping Zheng,Xun Zhu

DOI: https://doi.org/10.1016/j.biortech.2018.08.116

IF: 11.4

2018-01-01

Bioresource Technology

Abstract:In order to solve the technical bottleneck that the biomass yield and lipid accumulation cannot be increased simultaneously during microalgae growth, a heterotrophic-assisted photoautotrophic biofilm (HAPB) growth mode of Chlorella vulgaris was constructed. The light penetration capability of the microalgae biofilm formed through heterotrophic-assisted photoautotrophic growth was 64% stronger than that formed by photoautotrophic growth. Due to the different demands of autotrophic and heterotrophic growth of microalgae, the nutrient environment and growth conditions were optimized to fully utilize the advantages and potentials of the HAPB culture model. An optimized molar ratio of total inorganic carbon (CO2) to total organic carbon (glucose) (20:1) and a molar ratio of total carbon to total nitrogen (72:1) were obtained. The maximum specific growth rate of Chlorella vulgaris increased by 78% compared to that before optimization. Meanwhile, the lipid content and yield increased by 120% and 147%, respectively, up to 47.53% and 41.95 g m(-2).
Mixed Wastewater Coupled With Co2 For Microalgae Culturing And Nutrient Removal

Lili Yao,Jianye Shi,Xiaoling Miao

DOI: https://doi.org/10.1371/journal.pone.0139117

IF: 3.7

2015-01-01

PLoS ONE

Abstract:Biomass, nutrient removal capacity, lipid productivity and morphological changes of Chlorella sorokiniana and Desmodesmus communis were investigated in mixed wastewaters with different CO2 concentrations. Under optimal condition, which was 1: 3 ratio of swine wastewater to second treated municipal wastewater with 5% CO2, the maximum biomass concentrations were 1.22 g L-1 and 0.84 g L-1 for C. sorokiniana and D. communis, respectively. Almost all of the ammonia and phosphorus were removed, the removal rates of total nitrogen were 88.05% for C. sorokiniana and 83.18% for D. communis. Lipid content reached 17.04% for C. sorokiniana and 20.37% for D. communis after 10 days culture. CO2 aeration increased intracellular particle numbers of both microalgae and made D. communis tend to be solitary. The research suggested the aeration of CO2 improve the tolerance of microalgae to high concentration of NH4-N, and nutrient excess stress could induce lipid accumulation of microalgae.
Enhancement of Lipid Productivity with a Novel Two-Stage Heterotrophic Fed-Batch Culture of Chlorella Protothecoides and a Trial of CO2 Recycling by Coupling with Autotrophic Process

Tao Wang,Xiwei Tian,Tingling Liu,Zejian Wang,Wenyan Guan,Meijin Guo,Ju Chu,Yingping Zhuang

DOI: https://doi.org/10.1016/j.biombioe.2016.10.010

IF: 5.774

2016-01-01

Biomass and Bioenergy

Abstract:In this study, the influences of oxygen supply and nitrogen starvation on cell growth and lipid production by heterotrophic culture of Chlorella protothecoides were investigated in a 5-L stirred-tank bioreactor. The results demonstrated that both a low oxygen supply and nitrogen starvation are favorable for lipid accumulation, but limit cell growth and may therefore reduce the overall lipid production. Hence, a novel two-stage strategy for oxygen supply and nitrogen starvation was proposed in a batch culture, increasing the lipid content and yield on glucose by a factor 2.14 and 2.03 compared to the one-stage batch culture with high oxygen supply and sufficient nitrogen availability, respectively. Applying the two-stage process in a fed-batch culture further increased the lipid productivity to 175.2 mg/(L.h), giving a lipid yield of 195.6 mg/g. Furthermore, a dual-mode culture, coupling a heterotrophic process with autotrophic process, was implemented to allow for CO2 recycling. This improved the lipid productivity and carbon utilization efficiency, further contributing towards cost-effective and environment-friendly algal lipid production. (C) 2016 Elsevier Ltd. All rights reserved.
Enhancing CO2 fixation by microalgae in a Photobioreactor: Molecular mechanisms with exogenous carbonic anhydrase

Dandan Yao,Lingyu Wu,Ding Tan,Yongjie Yu,Qian Jiang,Yonghong Wu,Hui Wang,Yun Liu

DOI: https://doi.org/10.1016/j.biortech.2024.131176

Abstract:Microalgae biotechnology holds great potential for mitigating CO2 emissions, yet faces challenges in commercialization due to suboptimal photosynthetic efficiency. This study presents an innovative approach to improve CO2 mass transfer efficiency in microalgae using carbonic anhydrase (CA) in an internal LED flexible air-lift photobioreactor. Optimal conditions initial inoculation with 3.55 × 106 cells/mL and 20 % CO2 concentration, complemented by white LED lighting in Chlorella sp. CA regulated intracellular composition, enhancing chlorophyll, lipid, and protein contents. Metabolomics revealed elevated malic and succinic acids, associated with increased Ribulose 1,5-bisphosphate carboxylase oxygenase (RuBisCO) and Acetoacetyl coenzyme A (Acetyl-CoA) activities, facilitating efficient carbon fixation. CA also mitigated cellular oxidative stress by reducing reactive oxygen species (ROS). Furthermore, CA improved extracellular electron acceptor with currents surpassed CK. This CA-based microalgae biotechnology provides a foundation for future commercial applications, addressing CO2 emissions.
Growth and Nutrient Utilization of Green Algae in Batch and Semicontinuous Autotrophic Cultivation Under High CO 2 Concentration

Shan Liu,Perova Elvira,Yongkang Wang,Wei Wang

DOI: https://doi.org/10.1007/s12010-018-02940-9

2019-01-01

Applied Biochemistry and Biotechnology

Abstract:The growth performance of Chlorella protothecoides , Chlorella pyrenoidosa , and Chlorella sp. in autotrophic cultivation with 10% carbon dioxide (CO 2 ) was evaluated. The biomass production of C. protothecoides , along with its carbon, nitrogen (N), and phosphorus (P) utilization, in batch and semicontinuous autotrophic cultivation with 20% CO 2 was also determined. Among the three algae species, C. protothecoides obtained the highest biomass yield (1.08 g/L) and P assimilation (99.4%). Compared with the CO 2 flow rate and inoculation ratio in batch cultivation, light intensity considerably improved biomass yield, N and P assimilation, and CO 2 utilization. In the semicontinuous cultivation of C. protothecoides , a hydraulic retention time (HRT) of 8 days kept the system at a stable running state, thereby demonstrating that an HRT of 8 days was better than an HRT of 5 days. Among the three N/P ratios for C. protothecoides in semicontinuous cultivation with 20% CO 2 , 2:1 provided the highest biomass productivity (0.19 g/L/day) and CO 2 fixation rate (0.37 g/L/day). Therefore, this lower N/P ratio is more suitable than 10:1 and 50:1 for the growth of C. protothecoides with 20% CO 2 . Compared with the batch cultivation of C. protothecoides , semicontinuous cultivation improved the CO 2 fixation rate (by 1.5–2 times) and CO 2 utilization efficiency (by 3–6 times) of C. protothecoides .
Simultaneous Promotion of Microalgal CO 2 Assimilation, Biomass Accumulation, Lipid Production, and Wastewater Nutrient Removal by Adding 5-Aminolevulinic Acid

Yongfu Li,Ziyue Qiu,Hongwu Cui,Lu Wang,Litao Zhang

DOI: https://doi.org/10.1021/acssuschemeng.2c03089

IF: 8.4

2022-11-01

ACS Sustainable Chemistry & Engineering

Abstract:Microalgae-based wastewater management has the potential to serve dual purposes, including biofuel production and wastewater bioremediation. The current study investigates the role of 5-aminolevulinic acid (5-ALA) in the regulation of photosynthesis, biomass accumulation, lipid production, and nutrient removal from wastewater by Chlorella pyrenoidosa. In wastewaters, a 3 μM concentration of 5-ALA was considered optimal, as it increased the photosynthetic light reaction and CO2 assimilation of C. pyrenoidosa cells, thereby facilitating cellular growth, metabolism, and biomass accumulation. The acceleration of algal cellular metabolism increased the substrate pool and enhanced the expression of lipogenic genes, thereby promoting lipid production. Meanwhile, the removal of nutrients from wastewater was accelerated after the addition of 5-ALA. The accelerated nutrient removal from wastewaters following 5-ALA treatment was related to C. pyrenoidosa cell growth. C. pyrenoidosa is capable of utilizing nitrogen and phosphorus from wastewater and accumulating biomass. The biomass from microalgae can be used as a feedstock to produce biofuels. Therefore, the current study provided a novel strategy for simultaneously promoting CO2 assimilation, biomass accumulation, lipid production, and wastewater nutrient removal with microalgae. It is possible to use microalgae for the management of wastewater if research and development on commercializing technologies based on microalgae, both upstream and downstream, are carried out continuously.

chemistry, multidisciplinary,engineering, chemical,green & sustainable science & technology
The Capacity of Bicarbonate Capture of a Continuous Microalgae Photo-bioreactor System

Liu Guangmin,Qiao Lina,Zhang Hong,Xia Shumei,Zhao Dan

DOI: https://doi.org/10.1016/j.egypro.2014.11.1125

2014-01-01

Energy Procedia

Abstract:Feedstock for biofuel production, carbon sequestration and wastewater treatment could be reached simultaneously by microalgae, which have been considered as a promising method to face global warming and energy crisis. A microalgae photo-bioreactor system was investigated in this study. The freshwater microalgae, Chlorella sp. and Scenedesmus obliquus sp., were cultivated in continuous system. The capacity of bicarbonate capture of a continuous microalgae photo-bioreactor system was tested in this study. The effects of bicarbonate on biomass concentration, bicarbonate removal efficiency, and the removal efficiencies of NH4+-N concentration were investigated. And the changes of pH, dissolve oxygen (DO) of the microalgae suspensions in the photo-reactor were also considered. The results show the NH4+-N concentration removal efficiencies reached above 80% during the continuous experiment. The pH and DO levels of microalgae suspensions were stably during the study. The highest HCO3− removal efficiency is 63.9%. The results indicate the HCO3− fixation capacity of the microalgae photo-bioreactor could reach 0.015gL-1h-1. And the microalgae could grow by 0.41g (dry weight, DW) with capturing 1.0g HCO3−. In other word, producing 1.0g (DW) of microalgae could fix 2.42g HCO3−.
Transcriptome and Key Genes Expression Related to Carbon Fixation Pathways in Chlorella PY-ZU1 Cells and Their Growth under High Concentrations of CO 2

Yun Huang,Jun Cheng,Hongxiang Lu,Yong He,Junhu Zhou,Kefa Cen

DOI: https://doi.org/10.1186/s13068-017-0868-z

2017-01-01

Biotechnology for Biofuels

Abstract:The biomass yield of Chlorella PY-ZU1 drastically increased when cultivated under high CO2 condition compared with that cultivated under air condition. However, less attention has been given to the microalgae photosynthetic mechanisms response to different CO2 concentrations. The genetic reasons for the higher growth rate, CO2 fixation rate, and photosynthetic efficiency of microalgal cells under higher CO2 concentration have not been clearly defined yet.

Simultaneous Enhancement of Microalgae Biomass Growth and Lipid Accumulation under Continuous Aeration with 15% CO2

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Enhanced Lipid Productivity of Chlorella Pyrenoidosa Through the Culture Strategy of Semi-Continuous Cultivation with Nitrogen Limitation and Ph Control by Co2

Enhancing Lipid Production in Microalgae Chlorella PY-ZU1 with Phosphorus Excess and Nitrogen Starvation under 15% CO2 in a Continuous Two-Step Cultivation Process

Effect of CO₂ supply conditions on lipid production of Chlorella vulgaris from enzymatic hydrolysates of lipid-extracted microalgal biomass residues.

Revealing Mechanism and Influence of Microalgae Cells' Periodical Auto-Agglomeration Induced by High Concentration of Carbon Dioxide

Enhanced lipid accumulation of photoautotrophic microalgae by high-dose CO2 mimics a heterotrophic characterization

Unraveling non-linear dynamics of biomass, photosynthesis efficiency, and lipid accumulation in Chlorella vulgaris under mixotrophic cultivation

Regulation of carbon metabolic fluxes in response to CO 2 supplementation in phototrophic Chlorella vulgaris : a cytomic and biochemical study

Enhancing Microalgae Growth and Product Accumulation with Carbon Source Regulation: New Perspective for the Coordination Between Photosynthesis and Aerobic Respiration.

Biomass Producing and CO2 Capturing Simultaneously by Chlorella Vulgaris: Effect of CO2 Concentration and Aeration Rate

Influence of Exogenous CO2 on Biomass and Lipid Accumulation of Microalgae Auxenochlorella Protothecoides Cultivated in Concentrated Municipal Wastewater

High Concentration Co2 Sequestration by Using Microalgae in Staged Cultivation

Optimizing Culture Conditions for Heterotrophic-Assisted Photoautotrophic Biofilm Growth of Chlorella Vulgaris to Simultaneously Improve Microalgae Biomass and Lipid Productivity

Mixed Wastewater Coupled With Co2 For Microalgae Culturing And Nutrient Removal

Enhancement of Lipid Productivity with a Novel Two-Stage Heterotrophic Fed-Batch Culture of Chlorella Protothecoides and a Trial of CO2 Recycling by Coupling with Autotrophic Process

Enhancing CO2 fixation by microalgae in a Photobioreactor: Molecular mechanisms with exogenous carbonic anhydrase

Growth and Nutrient Utilization of Green Algae in Batch and Semicontinuous Autotrophic Cultivation Under High CO 2 Concentration

Simultaneous Promotion of Microalgal CO 2 Assimilation, Biomass Accumulation, Lipid Production, and Wastewater Nutrient Removal by Adding 5-Aminolevulinic Acid

The Capacity of Bicarbonate Capture of a Continuous Microalgae Photo-bioreactor System

Transcriptome and Key Genes Expression Related to Carbon Fixation Pathways in Chlorella PY-ZU1 Cells and Their Growth under High Concentrations of CO 2