Abstract:In cold and arid areas, variations of ambient temperature not only lead to a large amount of heat loss from anaerobic digestion reactors but also greater challenges in the stable production of biogas. Common temperature-controlled methods of biogas production, such as coal combustion, electric heating, biogas combustion and so on, are expensive and high energy-consuming. Openly, solar energy is economical and suitable for stable biogas production. However, no pilot studies have yet shown the feasibility of controlling the temperature of annual biogas production with solar energy in cold and arid areas. This paper first theoretically analyzed the energy balance between evacuated tube solar collectors and anaerobic reactors. Then a biogas production system was developed in Lanzhou City, China, consisting mainly of a 3 m 3 insulated anaerobic reactor and a solar collector with 30 sticks Φ58 × L1800mm evacuated tubes. Annual batch experiments have been carried out to test the feasibility of stable biogas production at a temperature-controlled by solar energy in cold and arid areas. The results show that dry anaerobic digestion with 20% total solid (TS) can start and operate smoothly even under the condition of low solar irradiation for 3–4 consecutive days. The system can run stability by anaerobic digestion at 26 ± 1 °C in winter and spring, by mesophilic (37 ± 1 °C) and thermophilic (52 ± 1 °C) anaerobic digestion in summer and autumn, which implies a highly efficient operation strategy for agricultural and animal husbandry wastes treatment. These theoretical and experimental results provide a scientific basis and engineering reference for the application of biogas production temperature-controlled by solar energy and have important value for the efficient and low-cost anaerobic digestion treatment of agricultural and animal husbandry wastes in cold and arid areas.

C309 HOW TO COMPENSATE THE LOST TEMPERATURE OF THE DIGESTER IN COLD CLIMATE(Heat Pump-3)

Examining A Hybrid Plug-Flow Pilot Reactor Foranaerobic Digestion of Farm-Based Biodegradable Solids

Using a Hybrid Heating System to Increase the Biogas Production of Household Digesters in Cold Areas of China: an Experimental Study

An Optimal Self-Excited Heating Method for Biogas Production under Cold Climate

Additional ratios of hydrolysates from lignocellulosic digestate at different hydrothermal temperatures influencing anaerobic digestion performance

Analysis of performance and potentials of energy saving and reduction for anaerobic digester in Wastewater Treatment Plant

Design and numerical analysis of a composite system of a household biogas digester with pretreatment

Energy management for maintaining anaerobic digestion temperature in biogas plants

Feasibility of annual dry anaerobic digestion temperature-controlled by solar energy in cold and arid areas

Design of Joint Heating of Biogas Digester by Solar Energy and Biogas Fueled Boiler in Cold Area

Experiment of Combined Warming System with Solar Energy and Biogas Boiler in Cold Areas

Research on Methane-Electricity-Heatpump System Model in Cold Area

Energy, exergy and economic analysis of an integrated ground source heat pump and anaerobic digestion system for Co-generation of heating, cooling and biogas

Research On Self-Energizing System Model Of Methane-Electricity-Heatpump In Cold Area

Continuous insulation strategy of organic waste composting in cold region: Based on cold-adapted consortium

A Hybrid System of Thermophillic Anaerobic Digestion and Heat Pump for Sludge Stabilization and Cascade Utilization of Energy in Municipal Sewage Treatment Plant

Household Biogas Technology in Cold Climate of Low-Income Countries: A Review on Sustainable Technologies for Accelerating Biogas Generation

Influence of Temperature on Biogas Production Efficiency and Microbial Community in a Two-Phase Anaerobic Digestion System

Design and Analysis of a Biogas Production System Utilizing Residual Energy for a Hybrid CSP and Biogas Power Plant

Overall Estimation of Mesophilic High-Rate Anaerobic Sludge Digestion in Internal Circulation Anaerobic Digester Integrated with Sewage Source Heat Pump

TECHNOLOGY ECONOMIC ANALYSIS OF HEAT PUMP TEMPERATURE RISING IN SEWAGE DISPOSAL PROCESS IN COLD CLIMATE AREA