Abstract:The addition of hydrogen is an effective way for improving the gasoline engine performance at lean conditions. In this paper, an experiment aiming at studying the effect of hydrogen addition on combustion and emissions characteristics of a spark-ignited (SI) gasoline engine under various loads and lean conditions was carried out. An electronically controlled hydrogen port-injection system was added to the original engine while keeping the gasoline injection system unchanged. A hybrid electronic control unit was developed and applied to govern the spark timings, injection timings and durations of hydrogen and gasoline. The test was performed at a constant engine speed of 1400rpm, which could represent the engine speed in the typical city-driving conditions with a heavy traffic. Two hydrogen volume fractions in the total intake of 0% and 3% were achieved through adjusting the hydrogen injection duration according to the air flow rate. At a specified hydrogen addition level, gasoline flow rate was decreased to ensure that the excess air ratios were kept at 1.2 and 1.4, respectively. For a given hydrogen blending fraction and excess air ratio, the engine load, which was represented by the intake manifolds absolute pressure (MAP), was increased by increasing the opening of the throttle valve. The spark timing for maximum brake torque (MBT) was adopted for all tests. The experimental results demonstrated that the engine brake mean effective pressure (Bmep) was increased after hydrogen addition only at low load conditions. However, at high engine loads, the hybrid hydrogen–gasoline engine (HHGE) produced smaller Bmep than the original engine. The engine brake thermal efficiency was distinctly raised with the increase of MAP for both the original engine and the HHGE. The coefficient of variation in indicated mean effective pressure (COVimep) for the HHGE was reduced with the increase of engine load. The addition of hydrogen was effective on improving gasoline engine operating instability at low load and lean conditions. HC and CO emissions were decreased and NOx emissions were increased with the increase of engine load. The influence of engine load on CO2 emission was insignificant. All in all, the effect of hydrogen addition on improving engine combustion and emissions performance was more pronounced at low loads than at high loads.

Investigation of An Electronically Controlled Hybrid Hydrogen–Gasoline Engine Powered Passenger Car

Investigation of Cold-Start Emission Control Strategy for a Bi-Fuel Hydrogen/gasoline Engine

Design of Hydrogen Enriched Compressed Natural Gas Engine Fuel System and Test Research

Performance of a hybrid hydrogen-gasoline engine under various operating conditions

Emissions Performance of a Hybrid Hydrogen–gasoline Engine-Powered Passenger Car under the New European Driving Cycle

Combustion and emissions characteristics of a hybrid hydrogen–gasoline engine under various loads and lean conditions

Experimental investigation of water injection and spark timing effects on combustion and emissions of a hybrid hydrogen-gasoline engine

Numerical investigation on gaseous fuel injection strategies on combustion characteristics and NO emission performance in a pure hydrogen engine

Experimental Study on the Effects of Hydrogen Injection Strategy on the Combustion and Emissions of a Hydrogen/Gasoline Dual Fuel SI Engine under Lean Burn Condition

Experimental Study on Performance and Emissions of a Spark Ignition Engine Fuelled with CNG-Hydrogen Mixtures

Experimental study on the combustion and emission performance of the hydrogen direct injection engine

Experimental Study on Performance and Emission of an Electric Turbocharged Hydrogen Direct Injection Engine

Computational Investigation of Combustion, Performance, and Emissions of a Diesel-Hydrogen Dual-Fuel Engine

Improving the Performance of a Gasoline Engine with the Addition of Hydrogen–oxygen Mixtures

Experimental study on improving gasoline engine performance by adding hydrogen to gasoline

Experimental investigation of the effect of hydrogen ratio on engine performance and emissions in a compression ignition single cylinder engine with electronically controlled hydrogen-diesel dual fuel system

Development and Validation of an On-line Hydrogen-Natural Gas Mixing System for Internal Combustion Engine Testing

Performance and Emissions of a Direct-Injection Engine Fueled with Natural Gas/Hydrogen Blends

Performance Study of Direct Injection Gasoline Engine Based on Hydrogen Injection Strategy

Research of Electronic Hydrogen Injection Control Strategy on Hydrogen-fueled Engines

Investigation of Gasoline Engine Cold-Start and Warm-up for Parallel Hybrid Electric Vehicle