Formation and Electromagnetic Properties of 0.1 BTO/0.9NZFO Ceramic Composite with High Density Prepared by Three‐Step Sintering Method

bin xiao,juncong wang,ning ma,piyi du
DOI: https://doi.org/10.1002/9781118771402.ch3
2014-01-01
Abstract:BaTiO3/Ni0.5Zn0.5Fe2O4 (BTO/NZFO) ceramic composite exhibit giant permittivity and high permeability simultaneously and could be potentially used in electronic devices. In this work, the sol-gel in situ derived 0.1BTO/0.9NZFO ceramic composites were sintered by conventional ceramic method and a modified three-step sintering process. In the new method, the ceramic composite was sintered initially at 1310 degrees C for 12 h, then sintered at 1325 degrees C for only 5 min, and ultimately cooled down rapidly within about 10 seconds. XRD, SEM and EDS were performed to analyze the phase composition, observe the morphology, and identify the elemental distribution of the ceramic composite. Results showed that the composite can be successfully formed through a carefully controlled step-sintering and rapid-cooling process. The composite exhibits a denser microstructure with larger grain size and increased density (by about 10%) compared with those prepared by conventional ceramic method. The effective permittivity of the newly-prepared composite is larger than 270k below 100 kHz, 3.5 times larger than that conventionally sintered at 1310 degrees C. A relatively low loss (similar to 0.3) was obtained at 30 kHz, 10.6% lower than conventionally prepared samples. The effective permeability reaches 150 (increased by 16.8%) with low magnetic loss (similar to 0.02). The three-step sintering method is a new effective way to break through the limitation of conventional sintering method and prepare ceramic composites with high density and thus enhanced dielectric and magnetic properties.
What problem does this paper attempt to address?