Flotation Rates and Zeta Potentials of Maceral Concentrates of Bituminous Coals

L. Zhang,J. C. Hower,R. Q. Honaker,W. Liu,D. Men

DOI: https://doi.org/10.1007/bf03402280

2015-01-01

Abstract:Maceral separation is one possible technique to expand coking coal resources, either by increasing the blending ratio of non- or slightly caking coal or rationally utilizing the coking coal according to the different behaviors of macerals in coking. The success of maceral enrichment for a given coal usingfiotation is dependent on the differences in flotation kinetic rate among macerals. This paper presents theflotation rates and zeta potentials of the vitrinite-rich and inertinite- rich maceral concentrates obtained from six coal samples of different ranks — from high-volatile B bituminous coal with mean random vitrinite reflectance (Rrandom) of 0.64 percent to low-volatile bituminous coal with Rrandom of 1.73 percent — using a float-sink procedure. The flotation results show that vitrinite-rich concentrates can be produced in tap water using froth flotation only with frother for the high-volatile B and A bituminous coal samples, but there was no good performance for the high-volatile C bituminous and medium- to low-volatile bituminous coal samples. The zeta potential results show that froth flotation could probably separate the high-volatile C bituminous coal samples well by adjusting pH, but there was no good performance for the higher-rank coal samples.