Abstract:In the present study, water-oil flow patterns and slug hydrodynamics were experimentally studied in square glass microchannels with various hydraulic diameters (Dh = 600 μm, 400 μm, 200 μm). The aqueous phase is the continuous phase while the organic phase is the dispersed phase. The ranges of flow rates of the continuous phase and the dispersed phase are 0–200 ml/h and 0–12 ml/h, 0–120 ml/h and 0–6 ml/h, and 0–60 ml/h and 0–2 ml/h in the microchannels with Dh = 600 μm, 400 μm and 200 μm, respectively. The results show that the hydraulic diameter has significant effects on flow patterns and three main flow patterns are observed, i.e., annular flow, slug flow and droplet flow. Generally, annular flow appeared at high flow rates of the dispersed phase and low flow rates of the continuous phase, while droplet flow appeared at low flow rates of the dispersed phase and high flow rates of the continuous phase. However, slug flow existed at comparable flow rates of the continuous and dispersed phases. A dimensionless analysis is carried out and a new dimensionless group including Weber number and Reynolds number is derived. The new defined dimensionless group performs well to develop a general flow pattern map. In addition, slug flow hydrodynamics are investigated as well in the present study, considering the slug length and slug velocity. Based on the present experimental results, a new scaling law is proposed to predict the slug length and it shows a good agreement with the experimental results. It has been widely reported that slug velocities depend linearly on the total flow rates of the two phases, which is consistent with the present study. The linear law provides a good prediction of the experimental slug velocities but different slopes are suggested in microchannels with different hydraulic diameters.

An Investigation on Hydrodynamic Characteristics of Liquid Slug in Oil-Gas-Water Three-Phase Slug Flow During Annular Tubes

Experiment and Numerical Simulation on Slug Fluidization of Geldart D Particles

WATER-OIL FLOW IN SQUARE MICROCHANNELS WITH A CROSSED JUNCTION

Cross-sectional Phase Distribution Measurement of Slug Flow in Small Channels

Electrical Impedance Characteristics of Slug Flow in Small Channels and Its Application to Void Fraction Estimation

Void Fraction Measurement of Bubble and Slug Flow in a Small Channel Using the Multivision Technique

A Method for Void Fraction Measurement of Bubble/slug Flow in Small Channels Based on Contactless Impedance Detection

PRESSURE FLUCTUATIONS OF LIQUID-LIQUID SLUG FLOW IN CROSS-JUNCTION SQUARE MICROCHANNELS

3d Reconstruction Of Slug Flow In Mini-Channels With A Simple And Low-Cost Optical Sensor

Void Fraction Measurement Of Gas-Liquid Two-Phase Flow In Mini-Pipe Based On Image Sequence

Slug Formation Analysis of Liquid–Liquid Two-Phase Flow in T-Junction Microchannels

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Slug Flow Hydrodynamics Modeling for Gas–Liquid Two-Phase Flow in a Pipe

Flowrate measurement of vertical oil-gas-water slug flow based on basic temperature and differential pressure signals

Investigations of the Formation Mechanism and Pressure Pulsation Characteristics of Pipeline Gas-Liquid Slug Flows

Flow rate measurements of slug flow by pressure differences of a venturi tube with a swirler

Investigation of Oil-Air Two-Phase Mass Flow Rate Measurement Using Venturi and Void Fraction Sensor

Gas slug parameter measurement based on double embedded U-tube electromagnetic wave phase sensor in gas-liquid slug flow

Characteristics of Gas-Liquid Slug Flow in Microchannel by Instantaneous Liquid Film Thickness Measurement

Experimental study on controllable pseudo-slug flow characteristics in horizontal pipe

Studies of gas-liquid two-phase flows in horizontal mini tubes using 3D reconstruction and numerical methods