Abstract:Solid-state anaerobic digestion has advantages of water conversation, convenient management and low energy consumption in winter. After the digestion, substrate contains low water and can be easily treated, thereby achieving zero emission. Under the condition of increasingly scarce water resource in the world, this technology conforms to the demand of resource utilization and water conversation. However, the process of solid-state anaerobic digestion was very complex and the solid-state anaerobic digestion of pig manure could easily lead to serious accumulation of volatile fatty acids (VFAs), which was the main inhibiting factor in solid-state anaerobic digestion of pig manure. Due to the low water content, the reaction of solid-state anaerobic digestion could not proceed normally, or even be ceased. Several measures could be used to minimize the accumulation of VFAs. Leachate recycling was one way to accelerate mass transfer rate, and proper recirculation rate could optimize the digestion process and improve the quantity and quality of biogas. Stratified inoculation was an alternative method for solid-state anaerobic digestion, in which inoculum was separated with substrate layer by layer. The reaction hypothesis suggests that stratified inoculation could be used to decrease accumulation of VFAs, however, only a few studies had investigated its effect to decrease VFAs accumulation. This study was mesophilic batch fermentation under the same temperature (37 ℃) and water content (80%) condition. To investigate the most efficient treatment of starting the fermentation and the variations of methane production and VFAs, co-digestions of pig manure with maize straw, leachate recycling and stratified inoculation were carried out with the solid-state anaerobic digestion of pig manure as control. Ammonia nitrogen content and soluble chemistry oxygen demand were analyzed. The performances of VFAs production and methane production in the treatments of co-digestion with dried maize straw, leachate recycling, and stratified inoculation in solid-state anaerobic digestion of pig manure were compared. The results were as follows: The performances in stratified inoculation reactors were the best, characterized by no lag time, the highest methane yield of 9.4 mL/(g·d) and the highest cumulative methane yield of 139.2 mL/g; leachate recycling could retain TVFAs at a low level of around 0.66 mg/g, and its cumulative methane yield was 16.7% lower than the stratified inoculation treatment; the concentration of TVFAs in the co-digestion and mono pig manure digestion reactors reached 19.08 and 19.83 mg/g, respectively, and methane yield was less than 0.1 mL/(g·d) in the first 15 days in both reactors. The most efficient treatment with the highest methane production and the quickest initiating can be obtained by contrasting different treatments, which thereby provides the reference for environmental disposal and utilization of the wastes with high solid and high organic matter content.

Study on Anaerobic Co-Digestion of Cow Manure, Maize Straw and Vegetable Waste

Co-digestion of rice straw,kitchen waste and toilet waste for biogas production

Characteristics of Biogas Producing by Anaerobic Co-Digestion of Agricultural Straw and Swine Wastewater Based on Improved Straw-Bed Bioreactor

Experimental Study on Optimization of Multiple Substrates Anaerobic Co-Digestion

Synergistic Effect of Multiple Raw Materials Anaerobic Digestion on Methane Production Performances

Improved Biogas Production from Rice Straw by Co-Digestion with Kitchen Waste and Pig Manure

Methane Production Dynamics of Co-Digestion of Cow Manure and Food Waste Under Mesophilic Condition

Optimization of the co-digestion of sewage sludge, maize straw and cow manure: microbial responses and effect of fractional organic characteristics

Biogas Production by Co-Digestion of Goat Manure with Three Crop Residues

Anaerobic co-digestion of cabbage waste and cattle manure: Effect of mixing ratio and hydraulic retention time

Anaerobic Co-Digestion of Rice Straw and Digested Swine Manure with Different Total Solid Concentration for Methane Production

Influences of different technological strategies on performance of anaerobic co-digestion of pig manure with straw in solid-state

Study on Improving Anaerobic Co-Digestion of Cow Manure and Corn Straw by Fruit and Vegetable Waste: Methane Production and Microbial Community in CSTR Process.

The studies on the methane production with solid state fermentation by mixed the rice straw and swine manures

Batch Anaerobic Co-Digestion of OFMSW (organic Fraction of Municipal Solid Waste), TWAS (thickened Waste Activated Sludge) and RS (rice Straw): Influence of TWAS and RS Pretreatment and Mixing Ratio

Anaerobic Co-Digestion of Kitchen Waste and Pig Manure with Different Mixing Ratios.

Dry Anaerobic Co-digestion of Cow Dung with Pig Manure for Methane Production

Application of Rumen Microorganisms for Enhancing Biogas Production of Corn Straw and Livestock Manure in a Pilot-Scale Anaerobic Digestion System: Performance and Microbial Community Analysis

Assessment of the effects of dry anaerobic codigestion of cow dung with waste water sludge on biogas yield and biodegradability

Anaerobic Co-digestion of Chicken Manure and Corn Straw: Gas Production, Biogas Fertilizer Effectiveness, and Microbial Diversity

Anaerobic Co-digestion of Rice Straw and Swine Feces