Abstract:Pressurized oxy-coal combustion has received wide attention recently due to its potential of high efficiency and low cost in CO2 capture. However, there is still a significant knowledge gap on the effects of pressure on the oxycoal and oxy-char combustion behaviors. In this study, oxy-char combustion experiments were carried out in a pressurized fluidized bed combustor, and the effects of pressure and oxygen concentration on the burnout time, reactivity and temperature of the char particles were investigated. The experimental results showed that the burnout time of the char particles decreased significantly with an increase in pressure from 0.1 MPa to 0.5 MPa. Besides, an increase in either the combustion pressure (within the range of 0.1 - 0.5 MPa) or the oxygen concentration (within the range of 10 - 30% O-2 in CO2) led to increases in the reactivity and temperature of the char particles, while the promotional effects of the pressure increase were weaker at the higher pressures. In order to better interpret the experimental results, a combustion model considering reaction kinetics, mass and heat transfer, and energy balance was developed and validated by the experimental results. The model simulation results showed that an increase in pressure would reduce the burnout time of char particles only when the combustion was kinetically controlled or combined kinetic-diffusion controlled. Once the combustion became diffusion-controlled, a further increase in pressure would have an insignificant effect on the char burnout time. Although the values of kinetic constants were different when different kinetic models, the global power-law model and Langmuir-Hinshelwood model, were adopted, the simulation results of the burnout time of the char particle under the pressurized fluidized bed combustion conditions were almost the same since the char combustion was mainly diffusion-controlled. The elevated combustion pressure accelerated both the char combustion rate and the char-CO2 gasification rate, while the carbon consumption ratio by gasification increased with pressure. Moreover, the enhanced gasification reaction had a great impact on the particle temperature especially under the higher oxygen concentration combustion conditions.

Modeling of an oxy-coal flame under a steam-rich atmosphere

Measurements and Modelling of Oxy-Fuel Coal Combustion

CFD modeling on char surface reaction behavior of pulverized coal MILD-oxy combustion: Effects of oxygen and steam

Reaction Behaviors of a Single Coal Char Particle Affected by Oxygen and Steam under Oxy-Fuel Combustion

Modeling of Single-Particle Char Combustion under O2/H2O Conditions: Effects of Temperature and Steam Concentration

Mathematical modeling of combustion in a grate-fired boiler burning straw and effect of operating conditions under air- and oxygen-enriched atmospheres

Computational modeling of oxy-coal combustion with intrinsic heterogeneous char reaction models

Experimental and Modeling Investigation of Oxy-Coal Combustion Based on Langmuir-Hinshelwood Kinetics and Direct Calculation of Char Morphology

Modeling Of A Single Char Particle Burning In Oxygen-Enriched O-2/N-2 And O-2/Co2 Environment

Effect of Steam on Ignition of Pulverized Coal Particles in Oxy-Fuel Combustion in a Drop Tube Furnace

CFD Simulation of the Steam Gasification of Millimeter-Sized Char Particle Using Thermally Thick Treatment

Modeling the Vaporization of Inorganic Matter from a Single Coal Char Particle Burning in an O-2/CO2 Atmosphere

A Kinetic Study on Char Oxidation in Mixtures of O2, CO2 and H2O

In situ experimental and modeling study on coal char combustion for coarse particle with effect of gasification in air (O2/N2) and O2/CO2 atmospheres

Effects of Steam and CO2 on the Characteristics of Chars During Devolatilization in Oxy-Steam Combustion Process

Experimental Study and Modeling of Oxy-Char Combustion in a Pressurized Fluidized Bed Combustor

Experimental Investigation of Ignition and Combustion Characteristics of Single Coal and Biomass Particles in O2/N2 and O2/H2O

Dynamic and kinetic studies on the oxy-coal combustion using multi-parameter high-speed diagnostics

Effect of Steam on Char Combustion Characteristics under a O2/CO2 Atmosphere

Experimental and kinetics analyses of a typical Zhundong coal reaction in O2/CO2/H2O atmosphere

Thermal-Gravimetry Study of Coal Char Combustion Model