Abstract:This paper presents the first characterization data of the lutein-rich microalgae Scenedesmus almeriensis, a new strain isolated within a farmer's greenhouse. The main objective is to determine the appropriate conditions for the culture of this microalgae and any factors that might enhance its lutein content. The maximum growth rate was determined first in batch cultures, resulting an initial estimate of 0.631/day. Then, the influence of environmental culture conditions such as temperature, pH, culture medium, external irradiance, and salinity were assessed operating in continuous mode at a dilution rate half the maximum previously determined. Finally, the possible interactions between irradiance and temperature were studied by means of a surface response analysis and the optimal conditions of irradiance and temperature were tested in a separate experiment. The results show that the medium proposed by [Mann JE, Myers J. On pigments, growth and photosynthesis of Phaeodactylum tricornutum. J Phycol 1968;4:349–55] was adequate for the growth of this strain and that increasing the initial nutrient concentration did not improve the performance of the cultures. Measurements of chlorophylls fluorescence showed that there was no photoinhibition even under the highest external irradiances tested (1700μE/m2s). The optimal pH was found to be 8.0. With regard to the temperature, this strain grew well in the range of 30–40°C, being clearly distressed in the experiments carried out at 48°C. Low to medium salinities, between 0 and 5gNaCl/L, were appropriate to promote growth rate. A response surface analysis predicted a maximum biomass productivity of 0.7g/Lday at 33°C and 1700μE/m2s, and a maximum lutein content of 0.54%d.wt. at 44°C and 1233μE/m2s. The experimental confirmation of the optimal conditions for lutein resulted in a biomass productivity of 0.73g/Lday with a lutein content of 0.53%d.wt., and therefore a lutein productivity of 3.8mg/Lday. The biomass of S. almeriensis is a rich source of lutein, about ten fold richer than the commercial source of this compound, Marigold flowers. The high lutein content and growth rate and the capacity to endure harsh environmental conditions make S. almeriensis a promising source of lutein.

Characterization, Extraction and Purification of Lutein Produced by an Indigenous Microalga Scenedesmus Obliquus CNW-N

Isolation and Purification of Lutein from the Microalga Chlorella Vulgaris by Extraction after Saponification.

Supercritical Fluid Extraction of Lutein from Scenedesmus almeriensis

Optimization of Lutein Recovery from Tetraselmis suecica by Response Surface Methodology

Comprehensive Analysis of Lutein and Loroxanthin in Scenedesmus obliquus: From Quantification to Isolation

Recent advances in lutein production from microalgae

Optimizing Chlorella vulgaris Cultivation to Enhance Biomass and Lutein Production

Polyol based deep eutectic solvent-assisted pretreatment for enhanced lutein extraction from Chlorella pyrenoidosa

Lutein production from microalgae: A review

Advances in microalgae-based lutein production and extraction: enhancing bioavailability and applications in health and industry

Preparative isolation and purification of lutein from the microalga Chlorella vulgaris by high-speed counter-current chromatography

Evolving perspectives on lutein production from microalgae - A focus on productivity and heterotrophic culture

Challenges and Potential in Increasing Lutein Content in Microalgae

Lutein production by microalgae using corn starch wastewater pretreated with rapid enzymatic hydrolysis

Extraction of lutein by aqueous two-phase system including both cholinium and imidazolium-based ionic liquids from wet microalgae

Light Induction of Seed Culture Accelerates Lutein Accumulation in Heterotrophic Fermentation of Chlorella Protothecoides CS-41

High-yield production of lutein by the green microalga Chlorella protothecoides in heterotrophic fed-batch culture.

High-cell-density heterotrophic cultivation of microalga Chlorella sorokiniana FZU60 for achieving ultra-high lutein production efficiency

Selection of extraction solvents for edible oils from microalgae and improvement of the oxidative stability

Influence of culture conditions on the productivity and lutein content of the new strain Scenedesmus almeriensis

Production and Rapid Extraction of Lutein and the Other Lipid-Soluble Pigments Fromchlorella Protothecoidesgrown under Heterotrophic and Mixotrophic Conditions