Abstract:During high pressure processing, the adiabatic compression increase of food materials would cause non-uniform temperature distribution and heat transfer, which would also influence the inactivation of bacteria, spore, enzyme and the quality of foods. Thermal conductivity of food materials at high pressure is a very important parameter for understanding heat transfer and temperature variation during high pressure processing. Available data and measuring method of thermal conductivity of food materials under high pressure are still scarce. In this study, a thermal conductivity probe developed based on the line heat source theory was installed in a high pressure chamber to measure thermal conductivity of food materials under high pressure. The thermal conductivity probe was calibrated using 1.5% agar gel whose thermal conductivity was very close to that of pure water but the convective effect during the measurement was eliminated due to the gel network at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results of calibration experiment indicated that thermal conductivity values of 1.5% agar gel measured under different pressures using the thermal conductivity probe were very close to that of reference data of pure water. Calibration factors defined as the ratio of measured and reference values of the thermal conductivity of 1.5% agar gel were found almost no effect by pressure. A general calibration coefficient value of 0.9944 (R square was 0.9997, observation number was 30) was obtained by linear regression analysis (zero intercept) of measured thermal conductivity values of 1.5% agar gel against reference values of pure water. The coefficient value was used for the correction of all experimental results in the following. Thermal conductivities of egg white, egg yolk, ham sausages and cream were measured at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results demonstrated that the thermal conductivities of these selected food materials at high pressure conditions were higher (up to 28%) than that of the sample at the atmospheric pressure conditions and had a tendency to increase with increasing pressure. Results at atmospheric pressure in this study were compared to estimate values using empirical equation based on water content. The measured thermal conductivities of egg yolk (0.43 W/(m·℃)), ham sausages (0.45 W/(m·℃)) and cream (0.49 W/(m·℃)) were very close to the estimated values (egg yolk 0.40 W/(m·℃), ham sausages 0.43 W/(m·℃), cream 0.41 W/(m·℃)) , while the measured value of egg white (0.65 W/(m·℃)) was significantly higher than that of the estimated value (0.53 W/(m·℃)) as well as that of pure water. The reason probably was that the flowability of egg white caused the generation of convective heat transfer. Measured thermal conductivities of egg white decreased at pressure higher than 300 MPa which was different from other three materials. The reason probably was that the pressure processing more than 300 MPa induced coagulation of egg white resulting in decrease of flowability as well as convective heat transfer. The water content of food materials had a significant effect on thermal conductivity. In general, the higher the water content, the higher the thermal conductivity. This rule was also confirmed at high pressure as the thermal conductivity from highest to lowest in order being egg white (83.1% water) > ham sausages (63.5%) > cream (57.5%) > egg yolk (50.7%). An empirical equation was established for prediction of the thermal conductivity of food materials at high pressure. The fourth-order polynomial was used to fit the thermal conductivity values of egg white, egg yolk, ham sausages and cream at pressure range from 0.1 to 400 MPa with temperature of 25℃. The regression coefficients of these equations were all above 0.91. This study could provide basic scientific datas for high pressure processing of food materials.

Coagulation of Egg White of Soft-Shell Turtle (pelodiscus Sinensis) at High Pressure or High Temperature

Cross-Linking of White Proteins in Soft-Shell Turtle Eggs Using Transglutaminase, Reductant, and Thermal Pretreatment

Ultra High Pressure Increasing Thermal Conductivity of Food Materials

Effect of Heat Treatment on White Shrimp (litopenaeus Vannamei) Quality

High Pressure Shelling of Shrimp and Quality Improvement

Effects of Thermal Processing on the Texture and Collagen Characteristics of Ready-to-eat Chicken Claw

Study on the enhancement effect and mechanism of heat-induced gel strength of duck egg white by emulsified lipids

Translucency mechanism of heat-induced pigeon egg white gel

Effects of Ultra High Pressure Treat on the Properties of Myofibrillar Protein from Duck Muscle Containing Modified Starch

Quantitative Proteomic Analysis of Chicken Egg White and Its Components.

DESCRIPTIVE ANALYSIS OF PRECOOKED EGG PRODUCTS AFTER HIGH‐PRESSURE PROCESSING COMBINED WITH LOW AND HIGH TEMPERATURES

Formation mechanism of high-viscosity gelatinous egg white among “Fenghuang Egg”: Phenomenon, structure, and substance composition

Physicochemical Properties and Microstructure of Surimi Treated with Egg White Modified by Tea Polyphenols

Quantitative proteomics provides insights into the mechanism of the differences in heat-induced gel properties for egg white proteins with different interior quality during ageing in laying hens

Effects of High Hydrostatic Pressure on Color, Texture, Microstructure, and Proteins of the Tilapia (orechromis Niloticus) Surimi Gels.

Towards the perfect soft-boiled chicken eggs: defining cooking conditions, quality criteria, and safety assessments

Effect of Different Heat Treatments on In Vitro Digestion of Egg White Proteins and Identification of Bioactive Peptides in Digested Products

Improvement of gel properties and digestibility of the water-soluble polymer of tea polyphenol-egg white under thermal treatment

Effects of High-Pressure Processing on the Cooking Loss and Gel Strength of Chicken Breast Actomyosin Containing Sodium Alginate

Lipid profiles of Chinese soft-shell turtle eggs (Pelodiscus sinensis)

Recent Advances in Heat-Induced Egg White Gelling Properties and Their Influencing Factors