Non-Saponifiable Extraction of Nd with P204-[P4446][NTf2]Ionic Liquid System
Shuai Guosheng,Zhao Yongzhi,Ma Ying
DOI: https://doi.org/10.13373/j.cnki.cjrm.XY20080028
2023-01-01
Abstract:The environmental pollution caused by the traditional extraction process is becoming more and more serious,and the sa-ponification wastewater produced by the saponification process and the volatile diluent used in extraction are the main ones.Exploring a method that uses non-saponified extraction and uses a non-volatile diluent is conducive to achieving environmental friendliness and conforms to industry development and wide-ranging requirements at local and overseas.In the comprehensive utilization of resources,the recovery of valuable metals in low-concentration wastewater has a lot of research space.Taking the rare earth metal Nd 3+ as an exam-ple,the P204-[P4446][NTf 2 ]ionic liquid system was used for the experiment of non-saponification extraction.In the process,the wa-ter phase concentration measurement adopted inductively coupled plasma optical emission spectroscopy （ICP-OES） and inductively coupled plasma mass spectrometry （ICP-MS）.The difference in extraction rate and extraction phenomenon of the system in HCl and HNO 3 media was compared,and the influence factors of HCl and HNO 3 media on the extraction results were explored.In terms of pH,the relationship between H + concentration and distribution ratio （D） in different media was studied,and the extraction mechanism was tried to be explored;in terms of shaking time,explored the extraction equilibrium time in different media and found the best condi-tions;in terms of temperature factors,the optimal extraction temperature was found through thermodynamic experiments in different media,enthalpy change（ΔH） and Gibbs free energy change（ΔG） were calculated by fitting curves to analyze the thermodynamic pro-cess.In terms of experiments with different molar ratios (n（P204）∶n(Nd 3+ )),the conditions of molar ratio (n（P204）∶n(Nd 3+ )) to achieve the best extraction resulted in different media were discussed.In terms of different concentrations of water phases,the extrac-tion rules and causes of different concentrations of water phases in different media in this system were discussed,and they were ex-plored from the aspects of ratio of two phases and mass transfer diffusion theory.The results were as follows:（1） The results of HCl and HNO 3 media showed that:in the case of a single variable,the extraction effect of HNO 3 media was better than that of HCl media,but there was no significant difference in the extraction phenomenon.（2） pH results showed that:for the two media,the lower pH val-ue,the higher the extraction rate,and the best extraction rate appeared at pH 4.0.（3） The shaking time results showed that:with the increase of shaking time,the extraction rate gradually increased and tended to be stable at 30 min.（4） Temperature results showed that:within the research range,the temperature increased,the extraction rate also increased,and the best condition was at 60℃.（5） The molar ratio (n（P204）∶n(Nd 3+ )) results showed that:when the molar ratio in HCl medium (n（P204）∶n(Nd 3+ )) was 5∶1,the extraction rate was＞90%,and the molar ratio in HNO 3 medium (n（P204）∶n(Nd 3+ )) was 4∶1,the extraction rate was＞90%.Finally,at pH 4.0,molar ratio (n（P204）∶n(Nd 3+ )) was greater than 5∶1,shaking time was 30 min and reaction was at 20℃，the extraction rate of the system in both HCl and HNO 3 media reached 99.99%.（6） Different water phase concentrations results showed that:within the scope of discussion,the extraction rate increased with the decrease of water phase concentration,and tended to be stable when the wa-ter phase concentration approached 5×10 -4 mol·L -1 .There were four conclusions:（1） Extraction under higher pH value could reduce the amount of acid used in the extraction process and save process costs.The extraction rate of HNO 3 medium was higher than that of HCl medium.This might be due to the inhibitory effect of Cl - on rare earth ions in HCl medium.Analyzing the experimental results,there might be a synergistic effect between P204 and[P4446][NTf 2 ]ionic liquids,that was,[P4446][NTf 2 ]ionic liquids might com-bine with the H + generated during the extraction process to promote the continuous extraction process.（2） The thermodynamic experi-ment showed thatΔH＞0 existed in both HCl and HNO 3 media,indicating that the extraction process was an endothermic reaction.（3） The shaking time during the extraction process was too long because the extraction system and the reaction process were continuously affected by diffusion and mass transfer for a long time.（4） The higher extraction rate of this system in the low-concentration aqueous phase might be due to the large decrease in the viscosity of the organic phase when the aqueous phase concentration was low,and[NTf 2 ] - improved the conductivity of the system and enhanced the combination of Nd 3+ and organic phase.