Abstract:The semi-hydrogenation of α,β-unsaturated aldehydes to the desired unsaturated alcohols with both high conversion and high selectivity remains a big challenge. Herein, we designed a sandwich-structured nanocatalyst for the highly selective hydrogenation of various α,β-unsaturated aldehydes (e.g., cinnamaldehyde, furfural, crotonaldehyde, and 3-methyl-2-butenal) to the targeted unsaturated alcohols. Highly accessible platinum nanoparticles were sandwiched between a metal-organic framework (MOF) core (i.e., MIL-88B(Fe)) and a MOF shell (i.e., Al-TCPP). In particular, the growth of the Al-TCPP shell was achieved by atomic layer deposition (ALD) of thin-film Al2O3 followed by phase transformation with a tetrakis(4-carboxyphenyl)porphyrin (H4TCPP) linker. The thickness of the Al-TCPP shell can be finely controlled by adjusting the cycle number of alumina ALD and the concentration of the H4TCPP linker during the phase transformation of Al2O3 to Al-TCPP. It was proven that the permeable MOF shells could serve as selectivity regulators for the activation of the CO bonds in α,β-unsaturated aldehydes (in preference to the CC bonds), leading to higher selectivity towards unsaturated alcohols as compared to the conventional surface supported Pt catalysts. Mechanistic insights showed that the enhanced catalytic performance was attributed to (i) the modified electronic state of sandwiched Pt nanoparticles by the two MOF layers and (ii) the steric hindrance effect on substrate diffusion through the sandwich-structured catalysts.

Pt/Al2o3 Catalyst Prepared from Water-In-Oil Microemulsion and Used in Catalytic Hydrogenation

Preparation of Pt/Al 2 O 3 catalyst in CTAB microemulsion and kinetics of m -chloronitrobenzene hydrogenation

Electrocatalysis of Oxygen Reduction on Carbon-Supported PtCo Catalysts Prepared by Water-in-oil Micro-Emulsion

Water-mediated Promotion of the Catalytic Conversion of Oleic Acid to Produce an Alternative Fuel Using Pt/C Without a H2 Source

Preparation of PtCl_6~(2-) Intercalated Mg/Al-hydrotalcite Catalyst and Its Catalytic Activities for the Hydrosilylation of Olefins

Solvent-free Selective Hydrogenation of O -Chloronitrobenzene over Large Palladium Particles on Oxygen-Poor Activated Carbon

Preparation of PtCl62-Intercalated Mg/Al-hydrotalcite Catalyst and Its Catalytic Activities for the Hydrosilylation of Olefins

Preparation and reactivity of UV light-reduced Pd/α-Fe2O3 catalyst towards the hydrogenation of o-chloronitrobenzene

UV Light-Assisted Synthesis of Highly Efficient Pd-Based Catalyst over NiO for Hydrogenation of o-Chloronitrobenzene

In Situ Growth of Tungsten Oxide on Alumina to Boost the Catalytic Performance of Platinum for Glycerol Hydrogenolysis

Influence of Support and Transition Metal (cr, Mn, Fe, Co, Ni and Cu) on the Hydrogenation of P-Chloronitrobenzene over Supported Platinum Catalysts

Fine-tuning Pt Nanoparticle and Coordination for Enhanced Catalytic Efficiency in Microwave-Assisted Methylcyclohexane Dehydrogenation over Pt/Al2O3 Catalysts

Catalytic Transfer Hydrogenation of the C=O Bond in Unsaturated Aldehydes over Pt Nanoparticles Embedded in Porous UiO-66 Nanoparticles

An exceptionally active and selective Pt-Au/TiO 2 catalyst for hydrogenation of the nitro group in chloronitrobenzene

Hydrothermal-treated Pt/Al2O3 as an excellent catalyst for toluene total oxidation

Bimetallic Pt-Co Nanoparticle Deposited on Alumina for Simultaneous CO and Toluene Oxidation in the Presence of Moisture

Enhancing the Chemoselective Hydrogenation of O-Chloronitrobenzene over Nanoporous Ni/NiAl3 Catalysts

Semi-hydrogenation of α,β-unsaturated aldehydes over sandwich-structured nanocatalysts prepared by phase transformation of thin-film Al2O3 to Al-TCPP

Nano porous PtRu alloy catalyst with enhanced synergic effect for selective hydrogenation of chloronitrobenzene

Effect of Transition Metal (cr, Mn, Fe, Co, Ni and Cu) on the Hydrogenation Properties of Chloronitrobenzene over Pt/TiO2 Catalysts

Regulating pore structures of carbon supports toward efficient selective hydrogenation of o-chloronitrobenzene on Pt nanoparticles