Abstract:The development of sustainable, efficient routes for conversion of glucose in biomass to 5-hydroxymethylfurfural (HMF), an important green intermediate in the production of value-added chemicals and fuels, has emerged due to the need to replace depletion of non-renewable fossil sources and climate change caused by their use. In this study, we describe a highly efficient reaction system for the production of HMF with a combination of homogeneous catalyst and heterogeneous catalyst in a polar cosolvent. The catalyst system consists of activated carbon (AC) supported aluminum (AC-Al) and maleic acid (MA) dissolved in a mixture of water, acetonitrile (ACN) and dimethyl sulfoxide (DMSO). Kinetic analysis of HMF production from glucose shows that carbon supported aluminum catalyst in combination with homogeneous maleic acid favored fructose dehydration to HMF instead of the formation of insoluble humins when compared to dissolved aluminum chloride and maleic acid in the same solvent. In addition, the rate constant of HMF hydrolysis to levulinic and formic acid was lower for AC-Al compared to dissolved Al. Response surface methodology (RSM), with central composite rotatable design (CCRD), identified the optimum conditions for glucose conversion to HMF as 168 °C for 11 min with a predicted molar yield of 50.3 mol%, which compared well to the experimentally verified yield of 45.8 mol% for these reaction conditions. To test the influence of glucose concentration on HMF yield, a range of initial glucose concentrations were examined. Results showed that the HMF yield increased with the decrease of weight percentage of glucose, suggesting that second order reactions result in humins formation.

Production of 5-Hydroxymethylfurfural from Glucose Using a Combination of Lewis and Brønsted Acid Catalysts in Water in a Biphasic Reactor with an Alkylphenol Solvent

Efficient One-Pot Production of 5-Hydroxymethylfurfural from Glucose in an Acetone–Water Solvent

Highly Efficient One-Pot Conversion of Glucose to 5-Hydroxymethylfurfural over Acid–Base Bifunctional MCM-41 Mesoporous Silica under Mild Aqueous Conditions

Conversion of glucose to 5-hydroxymethyl furfural in water-acetonitrile-dimethyl sulfoxide solvent with aluminum on activated carbon and maleic acid

A novel route towards high yield 5-hydroxymethylfurfural from fructose catalyzed by a mixture of Lewis and Brönsted acids

Conversion of Glucose to 5-Hydroxymethylfurfural in Deep Eutectic Solvent of Choline Chloride–Chromium Chloride

Ultra-Dilute SnCl4-Catalyzed Conversion of Concentrated Glucose to 5-Hydroxymethylfurfural in Aqueous Deep Eutectic Solvent.

Highly Efficient and Selective Preparation of 5-Hydroxymethylfurfural from Concentrated Carbohydrates Using Deep Eutectic Solvents

Experiments and Kinetic Modeling of Fructose Dehydration to 5-Hydroxymethylfurfural with Hydrochloric Acid in Acetone-Water Solvent

Highly Efficient Production of 5-Methoxymethylfurfural from Fructose in Dimethyl Sulfoxide/Amberlyst-15 Catalytic System

Selective 5-hydroxymethylfurfural production from cellulose formate in DMSO-H<sub>2</sub>O media

Maleic acid and aluminum chloride catalyzed conversion of glucose to 5-(hydroxymethyl) furfural and levulinic acid in aqueous media

Mechanistic Investigation of Cellulose Formate to 5-Hydroxymethylfurfural Conversion in DMSO-H2O

Continuous synthesis of 5-hydroxymethylfurfural from glucose using a combination of AlCl3 and HCl as catalyst in a biphasic slug flow capillary microreactor

Production of 5-Hydroxymethylfurfural from Hydrolysate of pretreated lignocellulosic biomass in a biphasic system reactor

Efficient Catalytic Conversion of Glucose into 5-Hydroxymethylfurfural by Aluminum Oxide in Ionic Liquid

Microwave‐Assisted Production of 5‐hydroxymethylfurfural from Glucose

Conversion of Glucose into 5-Hydroxymethylfurfural and Levulinic Acid Catalyzed by SO42–/ZrO2 in a Biphasic Solvent System

Tandem Catalytic Conversion of Glucose to 5-Hydroxymethylfurfural with an Immobilized Enzyme and a Solid Acid

Efficient conversion of glucose to 5-hydroxymethylfurfural by synergetic catalysis of enzymes and chemical catalysts towards potential large-scale continuous operation

Selective Catalytic Production of 5-Hydroxymethylfurfural from Glucose by Adjusting Catalyst Wettability.