Abstract:Magnetite nanoparticles (MNP) can boost the performance of biogas plants, but the effect of the anaerobic biodigester's microbial activity level, together with MNP characteristics, on improving methane production has not been investigated. Here, the influence of microbial activity and MNP size and concentration on the ability of magnetite to accelerate methanogenesis was studied in batch anaerobic digestion experiments. We found that magnetite can enhance methane production with low‐activity anaerobic microorganisms. Still, the size and dose of the magnetite nanoparticles require careful selection to avoid adverse effects, which is less relevant when the microbial consortia exhibit a high methanogenic activity. Magnetite nanoparticles can boost methane production via direct interspecies electron transfer. However, the combined effect of inoculum and particle characteristics on magnetite's methanogenesis stimulation is poorly understood. Here, the influence of inoculum type, particle size, and particle concentration on the ability of magnetite to accelerate methanogenesis was studied in batch anaerobic digestion experiments. Fresh and degassed mesophilic digester sludge was used as inoculum, representing methanogenic communities in the exponential or stationary growth and endogenous decay phases, respectively. Three magnetite particle size ranges, small (50–150 nm), medium (168–490 nm), and large (800 nm–4.5 μm), at two different concentrations (2 and 7 mM) were used. With degassed sludge, the effect of magnetite on the methane production rate was weak and depended on the particle size and concentration. Only magnetite of medium size at both 2 and 7 mM significantly increased the methane production rate by 12% compared to the control with no magnetite. The lag phase was reduced by 17% compared to the control, only with 2 mM of both small and medium size magnetite. Conversely, adding magnetite into fresh sludge significantly increased the methane production rate by an average of 32% while simultaneously decreasing the lag phase by 15%–40%, as compared to the control, independently of the magnetite's size and concentration. The stimulation of methane production depends on magnetite and inoculum characteristics.

Anaerobic Co-Digestion of Animal Manure and Wheat Straw for Optimized Biogas Production by the Addition of Magnetite and Zeolite

Effect of Magnetite Powder on Anaerobic Co-Digestion of Pig Manure and Wheat Straw

Magnetite Modified Zeolite As an Alternative Additive to Promote Methane Production from Anaerobic Digestion of Waste Activated Sludge

Combined Effect of Zero Valent Iron and Magnetite on Semi-Dry Anaerobic Digestion of Swine Manure

Enhancing Anaerobic Digestion of Kitchen Wastes Via Combining Ethanol-Type Fermentation with Magnetite: Potential for Stimulating Secretion of Extracellular Polymeric Substances.

Investigation on the Effect of Different Additives on Anaerobic Co-Digestion of Corn Straw and Sewage Sludge: Comparison of Biochar, Fe3O4, and Magnetic Biochar

Enhanced two-phase anaerobic digestion of waste-activated sludge by combining magnetite and zero-valent iron

Inorganic additives to increase methane generation during anaerobic digestion of livestock manure: a review

Enhanced Anaerobic Digestion of Cow Manure and Rice Straw by the Supplementation of an Iron Oxide–Zeolite System

Magnetite Nanoparticles and Carbon Nanotubes for Improving the Operation of Mesophilic Anaerobic Digesters

Effect of microscale ZVI/magnetite on methane production and bioavailability of heavy metals during anaerobic digestion of diluted pig manure

Roles of magnetite and granular activated carbon in improvement of anaerobic sludge digestion.

Effect of Nano-Magnetite and Ethanol on Methane Production in the Anaerobic Digestion of Wheat Straw

Insights of Enhancing Methane Production under High-Solid Anaerobic Digestion of Wheat Straw by Calcium Peroxide Pretreatment and Zero Valent Iron Addition

Optimizing feeding composition and carbon-nitrogen ratios for improved methane yield during anaerobic co-digestion of dairy, chicken manure and wheat straw.

Optimization of dry anaerobic co-fermentation of sludge and corn straw with magnetite (Fe3O4)

Investigation into the Effects of Different Recycled Magnetic Additives on Anaerobic Co-Digestion of Sludge and Straw

Interaction between magnetite and inoculum characteristics in accelerating methane production kinetics

Magnetite Enhances Anaerobic Digestion and Methanogenesis of Fresh Leachate from a Municipal Solid Waste Incineration Plant

Strategy to Enhance Semi-Continuous Anaerobic Digestion of Food Waste by Combined Use of Calcium Peroxide and Magnetite.

Enhanced anaerobic digestion of primary sludge with additives: Performance and mechanisms