Abstract:Graphical and Lay Summary The study introduced a single‐step method with extraction efficiency comparable to the Folch method, maintaining fatty acid composition. Through optimization, ethanol consumption was reduced by about 50%, and the process was scaled up to a 4 L glass reactor, resulting in a significant 25% increase in DHA yield from the total FAEE oil. Notably, impurities were removed during FAEE oil decolorization in the reactor before HPLC purification of DHA from FAEE oil for biodiesel. A novel approach for in situ transesterification, extraction, separation, and purification of fatty acid ethyl esters (FAEE) for biodiesel and docosahexaenoic acid (DHA) from Thraustochytrid biomass has been developed. The downstream processing of Thraustochytrids oil necessitates optimization, considering the higher content of polyunsaturated fatty acids (PUFA). While two‐step methods are commonly employed for extracting and transesterifying oil from oleaginous microbes, this may result in oxidation/epoxidation of omega‐3 oil due to prolonged exposure to heat and oxygen. To address this issue, a rapid single‐step method was devised for in situ transesterification of Thraustochytrid oil. Through further process optimization, a 50% reduction in solvent requirement was achieved without significantly impacting fatty acid recovery or composition. Scale‐up studies in a 4 L reactor demonstrated complete FAEE recovery (99.98% of total oil) from biomass, concurrently enhancing DHA yield from 16% to nearly 22%. The decolorization of FAEE oil with fuller's earth effectively removed impurities such as pigments, secondary metabolites, and waxes, resulting in a clear, shiny appearance. High‐performance liquid chromatography (HPLC) analysis indicated that the eluted DHA was over 94.5% pure, as corroborated by GC‐FID analysis.

Chemical Transformations of Fatty Acids in the Hydrolysis of Triglycerides. Selective Isolation of Oleic Acid from Rapeseed Oil under Sub- and Supercritical Water Conditions

Subcritical Water Hydrolysis of Fresh and Waste Cooking Oils to Fatty Acids Followed by Esterification to Fatty Acid Methyl Esters: Detailed Characterization of Feedstocks and Products

Subcritical water extraction of lipids from wet algae for biodiesel production

Optimisation of Enzymatic Pretreatment of Soybean Oil Deodoriser Distillate for Concentration of Tocopherols

Enzymatic Epoxidation of High Oleic Soybean Oil

Hydrothermal decarboxylation and hydrogenation of fatty acids over Pt/C.

Extraction of Rosa Laevigata and Analysis of Its Fatty Acid Components

Transesterification of Methyl Oleate for Sustainable Production of Biolubricant: Process Optimization and Kinetic Study

Lipase‐mediated plant oil hydrolysis—Toward a quantitative glycerol recovery for the synthesis of pure allyl alcohol and acrylonitrile

Low-cost liquid lipase selective deacidification of corn oil with high triglyceride yield

The impact of reducing fatty acid desaturation on the composition and thermal stability of rapeseed oil

Reaction-separation coupling process to purify α-linolenic acid based on the hydratase catalytic kinetics differentiation of flaxseed oil fatty acids

Role of Solvent in Catalytic Conversion of Oleic Acid to Aviation Biofuels

Continuous Flow Microreactors for the High-efficiency Enzymatic Synthesis of 10-Hydroxystearic Acid from Oleic Acid

Extraction, separation and purification of fatty acid ethyl esters for biodiesel and DHA from Thraustochytrid biomass

Extraction of Levulinic Acid from Aqueous Solution Using Trioctylamine at Different Temperatures

The change from hydrophilicity to hydrophobicity of HEC/PAA complex membrane for water-in-oil emulsion separation: Thermal versus chemical treatment

Preparing vegetable oils-based metalworking fluids by a hydrolysis-esterification two-step process

Influence of Thermal Hydrolysis on Composition Characteristics of Fatty Acids in Kitchen Waste

Enzymatic Deacidification and Aroma Characteristics Analysis of Rapeseed Oil Using Self-Made Immobilized Lipase CALB@MCM-41-C8

Recovery Utilization of Triolein for Producing Short Chain Alkane by Combining Biocatalysis and Inorganic Catalysis