Abstract:Supercritical CO2 can be used as a heat transfer fluid in a solar receiver, especially for a concentrating solar thermal power tower system. Such applications require better understanding of the heat transfer characteristics of supercritical CO2 in the solar receiver tube in a high temperature region. However, most of the existing experimental and numerical studies of the heat transfer characteristics of supercritical CO2 in tubes near the critical temperature region, and the corresponding heat transfer characteristics in the high temperature region are conducted. In this paper, a three-dimensional steady-state numerical simulation with the standard k-ε turbulent model is established by using ANSYS FLUENT for the flow and heat transfer of supercritical CO2 in a heated circular tube with an inner diameter of 6 mm and a length of 500 mm in the high temperature region. The effects of the fluid temperature (823–1023 K), the flow direction (horizontal, downward and upward), the pressure (7.5–9 MPa), the mass flux (200–500 kg·m–2·s–1) and the heat flux (100–800 kW·m–2) on the convection heat transfer coefficient and Nusselt number are discussed. The results show that the convection heat transfer coefficient increases while Nusselt number decreases nearly linearly with fluid temperature increasing. Both fluid direction and pressure have negligible effects on the convection heat transfer coefficient and Nusselt number. Moreover, the convective heat transfer coefficient and Nusselt number are enhanced greatly with the increasing of mass flux and the decreasing of heat flux, which is more obvious at a higher heat flux. The influences of buoyancy and flow acceleration on the heat transfer characteristics are also investigated. The buoyancy effect can be ignored within the present parameter range. However, the flow acceleration induced by the high heat flux significantly deteriorates the heat transfer preformation. Moreover, eight heat transfer correlations of supercritical fluid in tubes are evaluated and compared with the present numerical data. The comparison indicates that the correlations based on the thermal property modification show better performance in the heat transfer prediction in the high temperature region than those based on the dimensionless number modification. And Nusselt number predicted by the best correlation has a mean absolute relative deviation of 8.1% compared with the present numerical results, with all predicted data points located in the deviation bandwidth of ±20%. The present work can provide a theoretical guidance for the optimal design and safe operation of concentrating solar receivers where supercritical CO2 is used as a heat transfer fluid.

Numerical Study of the Transient Heat Transfer in He II for Superconducting Device Cooling: A Comparison to Gorter-Mellink Equation

COMPUTER SIMULATIONS ON MELTING PHENOMENA OF QUANTIZED FLUX LINES IN TYPE-II SUPERCONDUCTORS

Numerical Study on the Working Performance of a G-M Cryocooler with a Mechanically Driven Displacer

Study of the transient thermal wave heat transfer in a channel immersed in a bath of superfluid helium

Transient Heat Transfer from Thin Wires to A Bath of Sub-Cooled Superfluid Helium

Flow and Heat Transfer Characteristics of Supercritical Helium for Magnet Cooling

Numerical Analysis on the Thermal Responses of Near-Critical Fluid to Transient Cooling Process

Numerical Investigation on Heat Transfer Enhancement of Supercritical Co2 Flowing in Heated Vertically Upward Tubes

Numerical Simulations of Sub-Atmospheric J-T Heat Exchanger for Superfluid Helium Cryogenic System

Heat transfer from flat surface confined in parallel channels to He II

Numerical Investigation on Heat Transfer of Supercritical CO2 in Solar Receiver Tube in High Temperature Region

Experimental and Simulation Investigation on Heat Transfer Characteristics of In-Tube Supercritical CO2 Cooling Flow

Superheating fields of superconductors: Asymptotic analysis and numerical results

Two Step Phase Transition Model of Heat Transfer in Bath of Subcooled Superfluid Helium

Numerical Investigation for Heat Transfer of Supercritical Co2 Cooled in A Vertical Circular Tube

Numerical Investigation on the Mixed Convection and Heat Transfer of Supercritical Water in Horizontal Tubes in the Large Specific Heat Region

Numerical Simulation and Comparison of Turbulent Heat Transfer in Supercritical and Subcritical Water

Numerical investigation of cooling heat transfer to supercritical CO2 in a horizontal circular tube

Analysis of experimental conditions for simultaneous measurements of transport and magnetotransport coefficients of high temperature superconductors

Numerical Investigation on Conjugate Cooling Heat Transfer to Supercritical Co2 in Vertical Double-Pipe Heat Exchangers

Numerical investigation of transient phase-change transpiration cooling based on variable properties of coolant