Abstract:The magnetoelectric effect (ME) is an important strain mediated-phenomenon in a ferromagnetic-piezoelectric composite for a variety of sensors and signal processing devices. A bias magnetic field, in general, is essential to realize a strong ME coupling in most composites. Magnetic phases with (i) high magnetostriction for strong piezomagnetic coupling and (ii) large anisotropy field that acts as a built-in bias field are preferred so that miniature, ME composite-based devices can operate without the need for an external magnetic field. We are able to realize such a magnetic phase with a composite of (i) barium hexaferrite (BaM) with high magnetocrystalline anisotropy field and (ii) nickel ferrite (NFO) with high magnetostriction. The BNx composites, with (100 - x) wt.% of BaM and x wt.% NFO, for x = 0-100, were prepared. X-ray diffraction analysis shows that the composites did not contain any impurity phases. Scanning electron microscopy images revealed that, with an increase in NFO content, hexagonal BaM grains become prominent, leading to a large anisotropy field. The room temperature saturation magnetization showed a general increase with increasing BaM content in the composites. NFO rich composites with x ≥ 60 were found to have a large magnetostriction value of around -23 ppm, comparable to pure NFO. The anisotropy field HA of the composites, determined from magnetization and ferromagnetic resonance (FMR) measurements, increased with increasing NFO content and reached a maximum of 7.77 kOe for x = 75. The BNx composite was cut into rectangular platelets and bonded with PZT to form the bilayers. ME voltage coefficient (MEVC) measurements at low frequencies and at mechanical resonance showed strong coupling at zero bias for samples with x ≥ 33. This large in-plane HA acted as a built-in field for strong ME effects under zero external bias in the bilayers. The highest zero-bias MEVC of ~22 mV/cm Oe was obtained for BN75-PZT bilayers wherein BN75 also has the highest HA. The Bilayer of BN95-PZT showed a maximum MEVC ~992 mV/cm Oe at electromechanical resonance at 59 kHz. The use of hexaferrite-spinel ferrite composite to achieve strong zero-bias ME coupling in bilayers with PZT is significant for applications related to energy harvesting, sensors, and high frequency devices.

Large Converse Magnetoelectric Effect in Metglas Fecobsi and 0.7Pb(mg1/3nb2/3)o-3-0.3pbtio(3) Laminated Composite

Converse Magnetoelectric Effect in Ni(Terfenol-D)/Pb(Zr,Ti)O-3 Bilayer-Laminated Composite

Large Converse Magnetoelectric Effect in Ferromagnetic Shape Memory Alloy Ni49Fe18Ga27Co6 and Pb(Zr0.52Ti0.48)O3 Laminates

Electric-Field-Controlled Magnetic Responses in Metglas and Lead Zirconate Titanate Laminated Composite

Large magnetoelectric effect in mechanically mediated structure of TbFe2, Pb(Zr,Ti)O3 and nonmagnetic flakes

Strong Converse Magnetoelectric Effect in a Composite of Weakly Ferromagnetic Iron Borate and Ferroelectric Lead Zirconate Titanate

A Cost-Effective Self-Biased Magnetoelectric Effect in SrFe12O19/Metglas/Pb(Zr,Ti)O3laminates

Giant Magnetoelectric Effect in Mechanically Mediated Composite Structure of TbFe2–Pb(Zr,Ti)O3–TbFe2 with Two Nonmagnetic Flakes

Large E-field Tunability of Microwave Ferromagnetic Properties in Fe50Co50-Hf/lead Zinc Niobate–lead Titanate Multiferroic Laminates

Giant Magnetoelectric Effect in Multiferroic Laminated Composites

Converse Magnetoelectric Effect In Ferromagnetic Shape Memory Alloy/Piezoelectric Laminate

Large room temperature magnetoelectric response in quasi 1–2 nanocomposite films on mica substrate

Magnetic-Field-Orientation Dependent Magnetoelectric Effect in FeBSiC/PZT/FeBSiC Composites

Giant Magnetoelectric Effect of A Hybrid of Magnetostrictive and Piezoelectric Composites

Direct and Converse Magnetoelectric Effects in Ni43Mn41Co5Sn11/Pb(Zr,Ti)O3 Laminate

Magnetoelectric Effects in Ferromagnetic/Piezoelectric Multilayer Composites

Resonant Magnetoelectric Coupling of Fe-Si-B/Pb(Zr,Ti)O3 Laminated Composites with Surface Crystalline Layers

A Novel Spinel Ferrite-Hexagonal Ferrite Composite for Enhanced Magneto-Electric Coupling in a Bilayer with PZT

Using magnetoelectric effect to reveal magnetization behavior of bulk and heavy ferromagnetic materials

Giant magnetoelectric effect under high bias fields in cylindrical bilayered Ni-PZT composites

Enhanced Self-Bias Magnetoelectric Effect in Locally Heat-Treated ME Laminated Composite