Abstract:In this study, we investigated the localized and concomitant precipitation of calcium (Ca)/magnesium (Mg)-bearing species and iron oxides/oxyhydroxides, and their depression characteristics to the pyrite floatability in flotation process at pH 9 and pH 10.5 with prolonged pre-oxidation. Contrary to the depression characteristics at pH 9, the incipient (within aeration times of 30 min) depression of pyrite floatability in Ca/Mg-bearing solutions was more obvious at pH 10.5, while the subsequent decline was only slightly when the pre-oxidation time was expanded to 120 min and 360 min. The competitive adsorption among Ca/Mg-bearing species and potassium amyl xanthate (PAX, C6H11OS2K, collector) at specific sites onto the pyrite surface was demonstrated by the regularly decreased zeta potential of the pyrite surface pretreated in Ca/Mg-bearing solutions. Further scanning electron microscopy-energy dispersive spectrometry demonstrated the concomitant secondary Ca/Mg/Fe-bearing precipitates on the pyrite surface. X-Ray photoelectron spectroscopy suggested strong reprecipitation of iron oxides/oxyhydroxides on the pyrite surface via acid–base complexation among Ca/Mg hydroxy species and iron hydroxy species. Incipient occupation efficiency of specific reaction sites by Ca/Mg-bearing species, which were mainly controlled by the metastable distribution of Ca/Mg hydroxy species and their electrostatic affinity with pyrite surface, was the crucial factor that influenced the competitive adsorption of xanthate and pyrite floatability. More obvious incipient depression at pH 10.5 rather than at pH 9 contributed to more effective Ca/Mg-bearing species and their higher affinity to pyrite surface at pH 10.5. The localized and concomitant precipitation of secondary Ca/Mg/Fe-bearing species leads to a slightly increased hydrophilic coverage upon the pyrite surface, thus a slowly decreased pyrite floatability with increasing pre-oxidation time.

Electrochemical Behaviors of Pyrite Flotation Using Lime and Sodium Hydroxide As Depressantors

Enhanced depression of lime on pyrite via pre-oxidation in weakly alkaline systems

Effective Flotation Separation of Chalcopyrite and Graphite Using Eco-Friendly Xanthan Gum As Depressant

Kinetic Investigation of Initial Oxidative Dissolution of Pyrite in Alkaline Media (pH 9–12) and Influence of Ca and Mg: A Fundamental Study for Pyrite Depression in Froth Flotation

An Electrochemical Study of Surface Oxidation and Collectorless Flotation of Pyrite

Utilization and Mechanisms of Tannic Acid as a Depressant for Chalcopyrite and Pyrite Separation

Insight on Exogenous Calcium/Magnesium in Weakening Pyrite Floatability with Prolonged Pre-Oxidation: Localized and Concomitant Secondary Minerals and Their Depression Characteristics

Fenton oxidation modification mechanism of pyrite and its response to Cu-S flotation separation: Experiment, DFT, XPS and ToF-SIMS studies

A review on electrochemical behavior of pyrite in the froth flotation process

Effect of D-arginine as a novel depressant on the flotation separation of chalcopyrite from pyrite at low alkalinity

Selective flotation of chalcopyrite from pyrite via seawater oxidation pretreatment

Selective depression of pyrite with a novel thiocarbonate in a pyrite-galena flotation system

Application and depression mechanism of sodium humate on flotation separation of molybdenite and pyrite

Selective Separation of Chalcopyrite from Pyrite Using Sodium Humate: Flotation Behavior and Adsorption Mechanism

Surface properties and flotation inhibition mechanism of air oxidation on pyrite and arsenopyrite

Pyrite Depression by Sodium Metabisulfite in Freshwater and Seawater with Copper Activation

Activation flotation of lime-depressed pyrite with carbon dioxide: Performances, mechanism and pilot-scale application

The Interaction between Iron Cyanide and Lead Ions in Pyrite Flotation

Flotation separation of chalcopyrite and pyrite via Fenton oxidation modification in a low alkaline acid mine drainage (AMD) system

Advances in depressants for flotation separation of Cu-Fe sulfide minerals at low alkalinity: A critical review