Appropriate Adding Time of Concentrated Monosodium Glutamate Wastewater As Acidity Adjusting and Nitrogen Loss Control Agent in High Temperature Composting
KONG Haiming,LIU Li,LI Tianyu,WANG Jibing,FANG Ping
DOI: https://doi.org/10.3785/j.issn.1008-9209.2015.08.131
2016-01-01
Abstract:Summary The pH rise of the compost mixture is one of the main causes for nitrogen volatilization loss in the composting process.As a consequence of organic degradation,accumulated ammonium nitrogen will trigger pH rise spontaneously.It is generally believed that ammonia nitrogen (NH 3) will volatilize once the pH of compost mixture exceeds 8.0.And the higher the pH is,the more the NH3 volatilization will be.In this way,the pH rise of mixture will result in substandard compost products,not only because its pH is out of the upper limit(pH=8.5)of the NY 525—2012 standard,but also significant decline of nutrition content due to NH3 volatilization.Hence,adjusting the pH of materials to control nitrogen loss becomes one of the hot issues in the organic fertilizer industry.A lot of chemical agents have been applied to adjust the pH in composting.However,most of them are difficult to implement efficiency and decrease production cost,let alone the dilution effects and imbalance of nutrition.The concentrated monosodium glutamate wastewater (CMGW) is an evaporative and concentrated liquid waste from discharged organic water in production of monosodium glutamate,characterized by rich nutrients and free heavy metal pollution.Previous studies have indicated that CMGW is a promising conditioning agent to adjust acidity and reduce NH 3 volatilization for composting,and the suggested optimum dosage is 2% of the mixture in mass. The appropriate adding time of CMGW for adjusting pH and decreasing nitrogen loss due to NH 3 volatilization in composting was further discussed in present study by a compost simulation experiment.The simulation experiment took place in a composting device(patent number:ZL 201010589910X)with the mixture of fresh pig manure and mushroom residues at a ratio of 3∶1 in mass,as well as 1% fermentation bacterial agent of the mixture.Three treatments were conducted as follows:1) M1 ,application of 2% CMGW before composting;2) M2 ,application of 2% CMGW at the 5th day of composting;3) CK,control group without CMGW. After composting,the pH of the control group without CMGW increased from 8.5 to 9.0,which exceeded the standard limit,and was significantly higher than that in the other two treatments with 2% CMGW during the whole composting process.Furthermore,a significant difference between the pH in the M1 and M2 treatments was also found,in which the pH was reduced by 1.0 1.5 units to 7.0 for M1 ,while just 0.2 0.3 units for M2 .The results suggested that the adding time played a remarkable role in acidity adjustment efficiency of CMGW,and the application before composting would be more effective.This suggestion was further testified by the change of nitrogen contents in composting. The NH +4 -N content of the compost mixture in the M1 treatment was significantly higher than that in M2 or CK treatment during the composting process,especially at the early stage. However,the maximal reduction of NH +4 -N content was also found in the M1 treatment,which showed an equal minimum NH +4 -N content in the other two treatments at the end of composting.Meanwhile,as the NH +4 -N content decreased,the NO-3 -N content of compost mixture in the M1 treatment rose so promptly that it was significantly higher than that in the M2 or CK treatment at the later stage of composting,but few changes were showed in the latter two treatments and there was no difference between them in the whole composting process.In addition,the total nitrogen content of the compost products in the M1 treatment was also significantly higher than that in the CK or M2 treatment at the end of composting.Nevertheless,the adding time of CMGW had no negative effect on the indexes of composting process,such as the temperature and moisture content in composting and the seed germination index of compost products. In conclusion,the acidity adjustment efficiency and the nitrogen content of compost mixture are significantly affected by the adding time of CMGW in composting.Specifically,the appropriate application of CMGW at the beginning of composting can not only adjust the pH of compost mixture to a qualified level,but also provide more nitrogen source(especially NH +4 -N) and promote the transformation of NH +4 -N to NO-3 -N,reducing nitrogen loss from NH +4 -N volatilization in composting eventually.