Abstract:Long-distance oil pipeline is the most economical way to transport the crude oil and liquid chemical raw materials. The spillage liquid may enter the covered drain to form the flame spread over sub-flash liquid fuel. In this paper, a self-designed fuel-storable quartz glass pipe with the size of 100 cm long and 10 cm inner diameter is used to simulate a long-narrow confined space. The n -butanol flame spread behavior in the circular confined space is investigated by controlling the sealing ratio of the tube. The results show that the flame spreading behavior in the confined space is significantly different from that in the open space. There is the flame shuttle behavior at the sealing ratio β = 10% and the self-extinguishing behavior of the flame occurs at β = 55%. As the sealing ratios β > 10%, there is an obvious "retraction" behavior, resembling flame spreading over a hydrocarbon fuel in an open environment. However, the controlling mechanism is essentially different. For flame spread over butanol in a tube, the flame retreating is due to the insufficient oxygen supply. By contrast, for the flame spread over hydrocarbon fuel in an open space, the flame retreating is due to the evident difference of the flashpoint and fire point of the hydrocarbon fuel. The flame pulsation frequency increases from 2.0 to 5.7 Hz as the sealing ratio increases from β = 2% to 40%; then, it decreases to 1.3 Hz at β = 55%. The increase of the pulsation frequency in the initial stage indicates that the flame burns inadequately due to the reduced oxygen supply in the large sealing ratio. At β = 2%, the instantaneous velocity alternates between a low speed of 1–3 cm s −1 and a high speed of 5–8 cm s −1 , with an average velocity of 1.9 cm s −1 . This flame spreading behavior is regarded as the quasi-uniform propagation. At β = 45%, the average velocity reaches 2.3 cm/s. At β = 55%, the average velocity of flame is 0.54 cm s −1 , indicating that the flame is difficult to spread forward. When the flame passes through the oxygen concentration sensor, there is a low oxygen concentration valley in the range of 1–5%. In middle area of the tube, the combustion can maintain owing to the oxygen concentration below 12%. This paper provides some theoretical support and guidance for fire safety and rescue in the long-narrow confined space.

Effect of the height of the liquid surface on the flame spread over porous soaked with combustible liquid

Experimental Study of Flame Spread over Diesel and Diesel-Wetted Sand Beds

Experimental study on continuous spill fire of liquid fuel on porous bed

Hydrodynamic analysis and flame pulsation of continuously spilling fire spread over n-butanol fuel under different slope angles

Experimental Study on the Effect of Sub-Flash Point Fuel Temperature on the Spread Characteristics of Spill Fire

Experimental Study on Flame Length and Pulsation Behavior of N-Heptane Continuous Spill Fires on Water

Spread and Burning Behavior of Continuous Spill Fires

Experimental investigation and modeling of the spread and burning behaviors of continuous spill fires on a water surface

Investigation of pulsating behavior and oxygen concentration of flame spread over sub-flash n-butanol fuel in a circular tube

Experimental Study on the Liquid Layer Spread and Burning Behaviors of Continuous Heptane Spill Fires

Experiments Investigating Fuel Spread Behaviors for Continuous Spill Fires on Fireproof Glass

Experimental study on spread radius and burning rate of spill fires on a fine sand substrate

EXPERIMENTAL STUDY ON CHARACTERISTICS OF FLAME SPREAD OVER THE SURFACE OF WOOD SHEETS WITH DIFFERENT WIDTH UNDER DIFFERENT INCLINED ANGLE

Experimental Study on Spread and Burning Characteristics of Continuous Spill Fire Leaked from a Point Source under Different Slopes

Motion of Liquid Convective Flow and Heat Transfer Analysis of Flame Spread over butanol fuel within narrow channels

Large-Scale Experimental Study on the Spread and Burning Behavior of Continuous Liquid Fuel Spill Fires on Water

Experimental Study of Continuously Released Liquid Fuel Spill Fires on Land and Water in a Channel

Experimental study of flame spread behavior and heat transfer mechanism over n-butanol fuel in trays of different widths

Experimental study of the horizontal subsurface flow trajectory and dynamic external radiation of flame spread over diesel

Experimental Study on the Dynamic Combustion Behavior of Thin Fuel Layer Caused by Instantaneous Leakage of Ethanol and Gasoline

Three-dimensional structures of flames over liquid fuel pools