Abstract:SummaryThe present study investigated the potential of different concentrations of molasses wastewater to produce bioelectricity, reduction of chemical oxygen demand (COD) and functionally active microbial community in microbial fuel cells (MFCs). Five different MFC setups were compared in which three were fed with molasses (two at room and one at 35°C temperature), while fourth and fifth were used as control reactors fed with distilled water and acetate, respectively. During first, second and third phases of the experiment; 1, 3 and 5 g L−1 molasses in distilled water were used as 500, 1000 and 1500 mg L−1 COD loading rate, respectively. Analysis of different parameters including pH, total dissolved solids (TDS) and electrical conductivity performed after 3 days interval due to 3 days hydraulic retention time, while COD, current, the voltage after 24 hours interval. The maximum voltage (1011 mV) and current (0.91 mA) were produced in MCF‐3 when 5 g L−1 of molasses was used, while maximum power density 1570.68 mW L−1 was produced by MFC‐1. The highest COD removal (95%) was found in MFC‐3 at 500 mg L−1 influent COD, comparable with control MFC‐5 with acetate which exhibited 97% COD removal at the same loading rate of acetate. High throughput DNA sequencing showed Clostridium sensu stricto abundance was higher among all other genera in all MFCs, ranges between 11 and 17 in MFCs with molasses, 18.3 in MFC with acetate and a lower value of 5.8 in control MFC without molasses. Romboutsia found higher in MFCs with molasses and acetate, might be responsible for higher electricity generation in these MFCs. Higher Shannon diversity and low abundance were found in MFC4 with distilled water while low diversity with higher abundance due to enrichment of certain genera under specific substrates was found in MFC 2 and 5 fed with molasses and acetate, respectively. It was concluded that MFC with molasses concentration 5 g L−1 showed more efficient power generation as compared to acetate, hence can be used to generate electricity while COD removal efficiency was almost the same with molasses and acetate.

Electricity Generation from Molasses Wastewater by an Anaerobic Baffled Stacking Microbial Fuel Cell

Continuous Electricity Generation with Piggery Wastewater Treatment Using an Anaerobic Baffled Stacking Microbial Fuel Cell

Electricity generation from starch processing wastewater using microbial fuel cell technology

Development of a Novel Membrane-less Microbial Fuel Cell (ML-MFC) with a Sandwiched Nitrifying Chamber for Efficient Wastewater Treatment

A Microbial Fuel Cell Producing Electricity Directly from Municipal Wastewater Treatment

A Novel UASB–MFC–BAF Integrated System for High Strength Molasses Wastewater Treatment and Bioelectricity Generation

Electricity generation in a membrane-less microbial fuel cell with down-flow feeding onto the cathode

Electricity Generation from Organic Wastewater Using a Continuous-Flow Single Chamber Microbial Fuel Cell

A novel pilot-scale stacked microbial fuel cell for efficient electricity generation and wastewater treatment.

Potential of molasses substrate for bioelectricity production in microbial fuel cell with the help of active microbial community

A Microbial Fuel Cell–membrane Bioreactor Integrated System for Cost-Effective Wastewater Treatment

[Electricity generation performance of two-chamber microbial full cell in the treatment of simulated wastewater]

Assessment of Power Generation from Dewatered Sludge using Membrane-Less Microbial Fuel Cell

A cooperative microbial fuel cell system for waste treatment and energy recovery

Bioelectricity Generation From Synthetic Wastewater Treatment in a Membrane-Less Microbial Fuel Cell Using Methylene Blue and/or Neutral Red as Mediators

Potential of Novel Wastewater Treatment System Featuring Microbial Fuel Cell to Generate Electricity and Remove Pollutants

Electrical and degradation characteristics of microbial fuel cell using biogas slurry as substrate

Thermal/alkaline pretreatment of waste activated sludge combined with a microbial fuel cell operated at alkaline pH for efficient energy recovery

Evaluating the efficiency of a mixed culture biofilm for the treatment of black liquor and molasses in a mediator-less microbial fuel cell

[Electricity Generation from Corn Steepwater Using Microbial Fuel Cell Technology].