Freeze-drying preservation of rat skin tissues
Wei Yang,Man Jiang,Wen-xin Geng,Xing-rong Yan,Hui-cong Du,Jing Wei,Liang-qi Liu,Jie Zhao,Li-wen Li,Fu-lin Chen
DOI: https://doi.org/10.3969/j.issn.1673-8225.2009.41.016
2009-01-01
Abstract:BACKGROUND: Researches on dry preservation of cells have been conducted. However, the dry preservation of tissue and organ remains poorly understood. OBJECTIVE: To optimize the condition of introducing trehalose into rat skins, and investigate the feasibility of dry preservation of rat skins. DESIGN, TIME AND SETTING: Observation-based experiment was performed at the Tissue Engineering Laboratory, College of Life Sciences, Northwest University from November 2007 to November 2008. MATERIALS: SD adult rats, weighing 150 g, were selected. Trehalose was purchased from Sigma, USA. METHODS: The condition of trehalose introduction was optimized by adjusting the trehalose concentration (50, 300, 500, 800, 1 000 mmol/L), incubation period (0.5, 4, 7 and 9 hours) and incubation temperature [4 ℃, 4 ℃-37 ℃ (phase transition) and 37 ℃]. Trehalose loaded skins were placed in DMEM with 100 g/L dimethyl sulfoxide for 30 minutes, and cooled using a rate-controlled programmed freezer with the rate of-1 ℃ to-80 ℃ per minute, finally freeze-dried with freeze-dryer. The viability of skin grafts was evaluated by carboxyfluorescein diacetate, histological observation, and methyl thiazolyl tetrazolium viability assay. Absorbance of fresh and formalin fixed skins was separately regarded as positive and negative controls. HS staining was performed to observe skin structure, followed by autotransplantation. MAIN OUTCOME MEASURES: Introduction of trehalose into rat skins in different trehalose concentrations, incubation temperatures and time; Morphological and histological observation after the skin being hydrated as well as the viability of hydrated and autotransplanted skins. RESULTS: The loading amount of trehalose in rat skins remarkably raised with the increasing trehalose concentrations till 800 mmol/L (P < 0.05), and no apparent change was observed beyond 800 mmol/L (P > 0.05). The uptake of trehalose in rat skin for 37 ℃ and phase transition groups was much higher than 4 ℃ groups (P < 0.05) but there was no significant difference between phase transition and 37 ℃ groups (P > 0.05). The amount of trehalose in rat skin at 4, 7, 9 hours of incubation was notably higher than 0.5 hour group (P < 0.05). However, no difference was found among 4, 7, and 9 hours groups, and trehalose loading efficiency in skins was no further increased after 7 hours of incubation (P > 0.05). The viability of freeze-drying skins was markedly higher than the negative control (P < 0.05) group under the optimum conditions (800 mmol/L trehalose at 37 ℃ for 7 hours of incubation), and morphology and histological observations were similar to fresh skin. The grafted skin could survive for 13 days after autotransplantation. CONCLUSION: Trehalose concentration of 800 mmol/L, 37 ℃ as incubation temperature, and 7 hours of incubation are the best conditions for loading freeze-drying preservation of rat skin.