Influence of Total Solid Content on Anaerobic Digestion of Swine Manure and Kinetic Analysis
Du Lianzhu,Liang Junfeng,Yang Peng,Gao Wenxuan,Zhang Keqiang
DOI: https://doi.org/10.3969/j.issn.1002-6819.2014.24.030
2014-01-01
Abstract:Anaerobic digestion was a suitable technology for agricultural waste management as it combined waste treatment, energy output and recycling of by-product which can be used in agriculture as nutrient. The total solid (TS) or organic loading rate, hydraulic retention times and others parameters will influence the performance of anaerobic digestion. Among of these factors, TS was an important factor which influenced the biogas production efficiency, characteristics of the digested and the economic benefits of biogas plants because the appropriate TS can improve the utilization efficiency of working volume and increase the volume biogas production of the reactors. In order to optimize the total solid of anaerobic digestion with swine manure, batch experiment was carried out to investigate the effects of different TS contents on anaerobic digestion at TS of 3.0%, 7.5%, 12.0%and 15.0%under mesophilic conditions (35℃). In the period of 62 d, the accumulative biogas production, volume percentage of CH4 in biogas, TS and VS, pH value before and after digestion were monitored. The biogas production and methane yields were key indicators which were used to evaluate the anaerobic digestion, and the first-order kinetic was used to model the anaerobic digestion process. The results showed that the biogas yields basing on VS decreased with total solids fraction increasing from 3.0%to 15.0%and the biogas yields were 579, 527, 356 and 237 mL/g. The CH4 yields at different solids fraction were 317, 326, 222 and 140 mL/g, respectively. The CH4 yields of 3.0% and 7.5% accounted for 66.9% and 68.8% of the theoretical methane productivity (474 mL/g) which was calculated by the protein, fat and carbohydrate content in swine manure. The maximum CH4 production rate of different TS appeared at 2 d, the values were 37.0, 24.4, 10.4 and 4.7 mL/(g·d), respectively and the CH4 production rate during the experiment decreased with the increasing of TS generally. The volume percentage of CH4 in biogas was between 67%and 74%after 22 d, the value of solids fraction at 15.0%was the lowest. TS and VS degradation efficiency of anaerobic digestion decreased with the increasing of solids fraction from 7.5%to 15.0%, TS and VS degradation efficiency at TS of 7.5%were 49.2%and 65.5%, but that of TS at 15.0% were 37.4% and 46.9%. The VS degradation efficiency at TS of 3.0% was lower than that of the others mainly attributed to the TS content in inoculum. The first-order kinetic was used to simulate the anaerobic digestion process of swine manure at different TS contents, the results indicated that it was suitable for modeling the digestion when the solids fraction were 3.0% and 7.5%, and the degradation rate constants were 0.126 and 0.063 d-1. The first-order kinetic was not fitting well for the TS content of 12.0%and 15.0%, this can be explained that there were obvious lag phase in anaerobic digestion at high total solids fraction, the other reasons were the accumulation of intermediate product such as volatile acid (VFA) or ammonia nitrogen which resulted in the inhibition for methanogens. Compared with total solids fraction of 3.0%, the biodegradability (BAD) of swine manure at 30 d decreased by 6.3%, 55.8%and 74.7%, the methane production ratio (MPR) decreased by 8.8%, 36.9% and 42.6% with the increasing of total solids fraction from 3.0% to 15.0%. The time BDA achieved at 58.0%needed were 18 and 30 d when the total solids fraction were 3.0%and 7.5%. At the end of this experiment, BAD of different TS content were 66.9%, 68.8%, 46.8%and 29.5%, respectively.