Abstract:Urea thermolysis and isocyanic acid hydrolysis over three kinds of zeolites are investigated experimentally and the main decomposition products, NH3 and HNCO, are focused on. The results gained using thermogravimetric analysis with heating rates of 2 degrees C/min from 50-500 degrees C show NH3 releases mainly in 133-250 degrees C and the main thermal product above 250 degrees C is HNC. NH3 release process appears double-peaked while HNCO triple-peaked. Zeolites shift urea decomposition to lower temperature and shorten the process. The experiments of urea thermolysis over zeolites were done in the fixed reactor at programmed temperature and constant temperature. Although zeolites enhance the production of both NH3 and HNCO, the yield ratio of NH3 increases to 1.1 from 0.9 when adding zeolites but the yield ratio of HNCO is always below 0.8. Under zeolites's catalytic effect, the peak of NH3 release and the second peak of HNCO release become stronger. Moreover, zeolites can result in the HNCO peaks integrating into a stronger peak at 500 degrees C. The total yield of NH3 and HNCO increases about 0.1-0.2 with zeolites and the catalytic effect is more obvious at low temperature. In the experiment of thermolysis with a urea-water spray, over 96% urea could decompose to NH3 and HNCO when the temperature is over 550 degrees C and the residence time is more than 1.0 s. Zeolites show good catalytic performance on HNCO hydrolysis to NH3 and the conversion of HNCO to NH3 increases with increasing temperature and reaches above 80% at 250 degrees C and can touch 100%. The catalytic effect on urea thermolysis and HNCO hydrolysis decreases in the order H-Y > H-beta > H-ZSMS, which might be due to the amount of acidic sites on the catalysts. The apparent activation energy of the hydrolysis reaction is so low that the overall hydrolysis reaction rate on catalysts is mainly determined by external and internal mass-transfer limitations.

Investigation on Thermal Decomposition Characteristics of Urea Solution under High Temperature

Advances in calcium carbonate thermal decomposition

Performance of Nano-Caco3 Coated with SiO2 on CO2 Adsorption at High Temperature

Investigation on Synthesis Conditions of Ni-CaO/Al2O3 Sorption Complex Catalyst by Hydrothermal Precipitation Method

The effect of BeO on heat transfer and durability of nano-CaO-based CO<sub>2</sub> adsorbents

HNCO Hydrolysis Performance in Urea-Water Solution Thermohydrolysis Process with and Without Catalysts

CO_2 absorption in aqueous ammonia and thermal decomposition of solid products

Experimental Investigation on the Properties of Urea Thermohydrolysis with Catalysts

Thermogravimetric Experiment of Urea at Constant Temperatures

Catalytic effect of cobalt ion on oxidative pyrolysis of cation exchange resin

Investigation on Effects of Na2CO3 on Selective Non-Catalytic Reduction of NOx

Influence of CaO on Urea Pyrolysis in the Selective Non-Catalytic Reduction Denox Process

Experimental study of the effect of sodium salts on selective non-catalytic reduction of urea

Catalytic Performance of Zeolites on Urea Thermolysis and Isocyanic Acid Hydrolysis

Experimental and computational study of the thermal degradation of primary amines used in CO 2 capture

Effect of urea thermal decomposition on diesel NOx-SCR aftertreatment systems

Effects of CO Content on Selective Non-Catalytic Reduction of NOx

Experimental and modeling study of the effect of CO and H2 on the urea DeNO(x) process in a 150kW laboratory reactor

Mechanism of the Reaction Between HNCO and CaO in the Urea-Selective Non-catalytic Reduction Denox Process

Characterization of Dairy Manure Hydrochar and Aqueous Phase Products Generated by Hydrothermal Carbonization at Different Temperatures