Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Impaction of mineral nano-refrigeration-oil on the saturated vapor pressure of HFC134a

Influences of Cold Intermediary R12, R600a on the Flock Point of Refrigerator Oil DRB/A32

Solubility And Miscibility For The Mixture Of (Ethyl Fluoride Plus Polyol Ester Oil)

Solubility of Refrigerant 1,1,1,2-Tetrafluoroethane in Then,n-Dimethyl Formamide in the Temperature Range from (263.15 to 363.15) K

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Research on Compatibility Between Ethyl Fluoride With/without Lubricant Oils, and Plastics and Elastomers

Vapor–liquid Equilibrium of Difluoromethane +1,1,1,2-Tetrafluoroethane Systems over a Temperature Range from 258.15 to 343.15K

An experimental study of PVTx properties in the gas phase for binary mixtures of HFO-1234yf and HFC-134a

Solubility and Miscibility for the Mixture of (ethyl Fluoride + Alkylbenzene Oil)

Study on Flow Boiling Heat Transfer Characteristics of R161/oil Mixture Inside Horizontal Micro-Fin Tube

Investigation on Liquid Density Data at the Bubble Point and Equations for the Refrigerant Hfc-404a over A Wide Temperature Range

Experimental Data and Description of the Phase Equilibrium in the Binary System of Ethyl Fluoride and Polyol Ester Oil (planetelf ACD 32)

Experimental analysis of vapour compression refrigeration system using nano lubricant with refrigerant R-134a

Gas Phase PVTx Properties for Binary Mixtures of HFC-161 and HFC-134a

The Boiling Heat Transfer Characteristics of the Mixture HFO-1234yf/oil Inside a Micro-Fin Tube

Experimental Study on Vapor Pressure of HFC-134a

Investigation on Materials Compatibility Using Nanoparticles Additive in Refrigerating System

Cooling and Tribological Performance Analyses of a Refrigeration System Using Nano-Fluids as Refrigerant and Lubricant

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Vapor-liquid Equilibrium Measurement and Heating Performance Modeling on Eco-Friendly Zeotropic Blends of CO2/R1234ze(Z) and CO2/R1336mzz(E)

Experimental and Theoretical Research on the Saturated Liquid Thermal Conductivity of HFO-1336mzz(E)