Abstract:<p>The local phase distribution of adiabatic air-water two-phase flow in churn-turbulent to annular flows was experimentally investigated using the Two-Sensor Droplet-Capable Conductivity Probe. The experiments were performed in a 2.54 cm inner diameter vertical round pipe at downward flows. Twelve flow conditions in churn-turbulent to annular flows were chosen for the current study. The inlet superficial gas velocity ranged from 5.68 m/s to 17.19 m/s, and the inlet superficial liquid velocity ranged from 1.21 m/s to 2.64 m/s. The DCCP-2 is able to distinguish droplets, liquid ligaments, bubbles, and continuous gas. The radial profiles of volume fraction, frequency, axial interfacial velocity, and chord length of droplets, ligaments and bubbles were measured. The experimental results showed that gas volume fraction had a center-peak distribution, and the maximum gas volume fraction in centerline could exceed 95%. The volume fraction of droplets was very low, only on the order of 0.1 %. Droplet concentration also showed a center-peak distribution. Both ligament and bubble volume fraction showed a near-wall peak distribution. The ligament volume fraction in the near wall region could reach 80%, which indicated the existence of a film region near the wall and likely includes surface waves on the film. The volume fraction profile of gas, droplets, ligaments, and bubbles showed the tomography structure in churn-turbulent to annular flows. The effects of flow conditions on phase distribution were also studied. An interesting feature was that both the increase of gas flux and the increase of liquid flux tended to increase the bubble volume fraction. The statistical distribution of droplet size was found to be invariant of radial position. The droplet velocity at centerline was generally larger than the superficial gas velocity, which can be attributed to the gravitational effects at downward flows.</p>

Non-Newtonian fluid-nitrogen two-phase flow pattern in noncircular minichannels

Liquid-liquid Two-Phase Flow and Mass Transfer in T-shaped Micro-Channel Network

Nanoscale fluid flows in the vicinity of patterned surfaces

EFFECTS OF INLET ARRANGEMENTS ON LIQUID-LIQUID FLOW PATTERNS IN CROSS-JUNCTION SQUARE MICROCHANNELS

Visual Study of Flow Pattern Evolution of Flow Boiling in A Microtube

Examining the interfacial behavior of Non-Newtonian gas-liquid two-phase flow in horizontal square microchannels

Liquid‐liquid Two‐phase Flow Patterns in a New Helical Microchannel Device

A New Method for Velocity Measurement of Gas-Liquid Two-Phase Flow Based on C~4D Technique

Experimental study of Taylor bubble flow in non-Newtonian liquid in a rectangular microchannel

Hydrodynamics of gas/shear-thinning liquid two-phase flow in a co-flow mini-channel: Flow pattern and bubble length

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

D211 Study on Behavior of Bubbles in Two-Phase Mixing Section of Microchannel

Experimental study of two-phase flow structure in churn-turbulent to annular flows

3D gas-liquid interfaces and flow characteristics of two-phase flows in horizontal tubes

Pola Aliran Dua Fase Gas - Fluida Non Newtonian Melalui Belokan Pipa

Numerical and experimental investigation of dripping and jetting flow in a coaxial micro-channel

Pulsatile flow of immiscible ternary hybrid nanofluid in a corrugated curved channel

Phase Distribution of Gas–Liquid Slug–Annular Flow in Horizontal Parallel Micro-Channels

Experimental Investigation on Two-Phase Flow Pattern of Ammonia Inside 4 Mm and 8 Mm Horizontal Smooth Tubes

Flow Pattern Variations of Viscoelastic Fluid Flows in Three‐dimensional Branching Channel

Characterization of Liquid-Liquid Two-Phase Flow Patterns and Mass Transfer Coefficients in Human-Shaped Microchannels