Abstract:Abstract The liquid film distribution in the helically coiled tube (HCT) is affected by curvature-induced centrifugal force and gravity force, showing more complex characteristics than straight tubes. However, due to the limitation of the measurement technology, the relevant data on liquid film in HCT are still rare. In this paper, based on the time-multiplexed excitation-probing scheme, a type of non-intrusive concentric conductance probes (CCPs) is developed at first. After reporting the operation principle of CCPs, the numerical simulation of potential field distribution in CCPs is conducted, and the effects of electrode structure parameters and liquid film thickness on the performance of CCPs are then analyzed in detail. It is found that in a certain range, the larger the inner electrode and outer electrode diameter, the greater the signal penetration depth (i.e., the larger the measurement range of liquid film thickness). Finally, the spatio-temporal distribution of liquid film on the wall of the HCT is experimentally studied using the optimized CCPs. The results indicate that this probe can realize the high-frequency accurate capture of liquid film flow details such as the occurrence and evolution process of liquid film inversion and the fluctuation characteristics of liquid film in HCT. The wave frequency of the liquid film is demonstrated to be not consistent along the circumferential direction. Using Strouhal number and Lockhart-Martinelli parameter, the wave frequency correlation at the maximum film thickness in the state of film inversion in HCT is obtained.

Study on the solid fraction measurement of TBAB clathrate hyrate slurry (CHS) using a conductance probe

Measurement of Solid Concentration Using Terahertz Technique

R/S Analysis of Acoustic Emission and Measurement of Slurry Mass Concentration in Loop Reactor

Measurement of Solid-Holdup in Multiphase System Based on Hydrophone Method

Void Fraction Measurement Of Gas-Liquid Two-Phase Flow Based On (Cd)-D-4 Technique

Solids Volume Fraction Measurement of Gas-Solid Two-Phase Flow Based on Terahertz Time-Domain Spectroscopy Technique

A Device and Method For Flowrate Measurement of Fluid in Small Channel Based on C~4D Technique

Measurement of Slurry Suspension Height in Stirred Tank by Multi-Scale Analysis of Acoustic Emission Technology

Measurement of gas and liquid flowing through holes on the compound tray

Thermal Conductivity Measurements of a Phase Change Material Slurry under the Influence of Phase Change

A Novel Method for Holdup Measurement of Three Phases by an Ultrasonic Device with the Flexible Substrate

An Electrical Conductivity Probe Method for Measuring the Local Solid Holdup in a Slurry System

Measurement of Gas and Liquid Flowing Through Holeson the Compound Tray

INVESTIGATION ON FLOW PROPERTIES OF CLATHRATE HYDRATE SLURRY IN CYLINDER PIPE

Experimental investigation on TBAB clathrate hydrate slurry flows in a horizontal tube: Forced convective heat transfer behaviors

Local Measurement of Bubbly Flow in Helically Coiled Tubes Using Double-Sensor Conductivity Probe

Experimental Investigation on Tetra-N-Butyl-Ammonium Bromide Clathrate Hydrate Slurry Flows in A Horizontal Tube: Flow Behavior and Its Rheological Model

Flow characteristics of TBAB hydrate slurry flow in horizontal tube

Solid Fraction Determination in Cold Storage by Tetra-N-butyl Ammonium Bromide Clathrate Hydrate Slurry

Optimization and application of the concentric conductance probes in liquid film thickness measurement in a helically coiled tube

Forced Flow and Convective Melting Heat Transfer of Clathrate Hydrate Slurry in Tubes