Abstract:Utilising solar thermal energy for membrane distillation desalination represents a green and sustainable solution for building environments in regions with a high correlation between water shortage and high solar irradiance. Today’s solar thermal-driven membrane distillation systems are designed with physically separated solar thermal collectors (e.g. flat plate or evacuated solar thermal collectors) and membrane distillation modules. In these systems, a thermal storage tank, a heat exchanger, and complex plumbing arrangements are required to control the heat and mass transfer between the solar collectors and the membrane distillation unit(s). Due to their high complexity and high capital/operational costs, these systems are rarely installed in buildings. To overcome these weaknesses, the present work conducts an experimental and numerical feasibility study of an integrated solar membrane distillation prototype (with the membrane distillation modules built directly into the evacuated solar tubes) for both potable water and/or thermal energy production. To the best of the authors’ knowledge, this elegant combination of an evacuated tube solar collector and a membrane distillation unit represents an innovative approach which couples two well-developed technologies into an efficient, yet relatively low cost, hybrid energy-water production system. Our experimental results revealed that 4–10 L per square meter of membrane area per hour of permeate flux is achievable when the feed temperature ranges from 50 to 70 °C, achieving a salinity level of 10–200 ppm from a 35,000 ppm (e.g. the salinity of seawater) feed. It was found that a system with a solar absorbing area of 1.6 m2 integrated with ∼0.2 m2 of membranes can produce ∼4 L of drinkable water and ∼4.5 kWh of heat energy (at 45 °C) per day (with an average daily solar exposure of 4 kWh/m2). We envision that this design could be beneficially deployed on the rooftops of residential and commercial buildings—buildings which require a continual supply of both potable water and domestic hot water.

Experimental Study of Thermoelectric Integrated Direct Distillation Water Purification Systems

EXPERIMENTAL STUDY ON A SOLAR DISTILLATION PLANT CHARACTERIZED WITH BUBLLING EVAPORATOR

Theoretical Investigation on Thermo-Electric Integrated Membrane Evaporation Subsystem

Establishment and Test Research of Experiment System for Seawater Desalination Based on Ocean Thermal Energy

Thermodynamic Analysis of Siphon Flash Evaporation Desalination System Using Ocean Thermal Energy

Modelling and Experiments on Ocean Thermal Energy for Desalination

An integrated, solar-driven membrane distillation system for water purification and energy generation

Study on a passive concentrating photovoltaic-membrane distillation integrated system

Towards the Optimization of a Photovoltaic/Membrane Distillation System for the Production of Pure Water

Thermodynamic analysis of direct heated solar desalination system

EXPERIMENTAL STUDY ON A DIRECTLY HEATED SOLAR DISALINATION SYSTEM

Modeling and simulation of direct contact membrane distillation system integrated with a photovoltaic thermal for electricity and freshwater production

Design and Experimental Study of an Indirect Heat Pump Distillation System for Treating High-Concentration Saline Wastewater

Performance analysis of a solar-driven integrated direct-contact membrane distillation and humidification–dehumidification system

Monolithic all-weather solar-thermal interfacial membrane evaporator

Enhanced Performance of Membrane Distillation Using Surface Heating Process

Membrane fabrication and configuration design development of photothermal membrane distillation (PMD)

Integration of Direct Contact Membrane Distillation and Solar Thermal Systems for Production of Purified Water: Dynamic Simulation

Experimental Performance Evaluation of an Integrated, LCPV/T Membrane Distillation System for Electricity and Seawater Desalination

Energy and Exergy Analysis of a Spray-Evaporation Multi-Effect Distillation Desalination System