Abstract:The precipitation and deposition of asphaltenes often cause great troubles to the recovery and transportation of crude oil. Adding polymer inhibitors is an effective approach to prevent asphaltenes from clogging. In this study, maleic anhydride-co-octadecene copolymers with imidazolyl, phenyl, and pyridyl pendants were synthesized. The inhibition behaviors of two extracted asphaltenes in the presence of these copolymers were investigated, which were also identified by the rheological tests of the heavy crude oil sample. The chemical structure of both asphaltenes was analyzed by Fourier transform infrared spectroscopy (FTIR), nuclear magnetic resonance (NMR), elemental analysis, and time-of-flight (TOF) spectrometry. Both asphaltenes A and B have a high aromaticity and low H/C. However, asphaltene B has a much higher aromaticity and polarity than that of asphaltene A. Ultraviolet–visible spectroscopy, turbidity meter, and dynamic light scattering (DLS) were employed to determine the precipitation behaviors of asphaltenes in the absence and presence of copolymers. The influence of intrinsic properties of asphaltenes, polymer concentration, and aromatic group grafting ratio on asphaltene precipitation were also compared. It is found that the initial precipitation point (IPP) of both asphaltenes is increased most by the copolymer containing 2-aminopyridine (PMO-2-P), while the copolymer containing N-(3-aminopropyl)imidazole (PMO-I) shows the worst inhibition performance. It is because that pyridine group has a stronger adsorption capacity with asphaltene than the imidazole group. The effect of various functional groups in copolymers on inhibiting asphaltene precipitation conforms to the following sequence: 2-aminopyridine > aniline > 4-aminopyridine > N-(3-aminopropyl)imidazole. It is also found that high polymer concentration and grafting ratio are beneficial to inhibit the asphaltene precipitation. As a result of the π–π conjugation and hydrogen-bonding attractions between the aromatic groups in the copolymers and the asphaltenes, the polymers can be stably adsorbed onto the surface of the asphaltenes and prevent their aggregation.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.energyfuels.1c01174?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.energyfuels.1c01174</a>.Further extraction steps of asphaltene A from the scraped pipeline deposit (Figure S1), density and elemental composition of heavy crude oil (Table S1), and detailed deduction process of asphaltene structure models (Table S2) (<a class="ext-link" href="/doi/suppl/10.1021/acs.energyfuels.1c01174/suppl_file/ef1c01174_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

CHANGES OF ASPHALTENE AFTER HYDROTREATING BY RUTHENIUM IONS CATALYZED OXIDATION

Structure Changes of Asphaltene in Residue Hydrotreating

STRUCTURE CHANGES OF ASPHALTENE UNITS IN RESIDUE HYDROTREATING

Insight into asphaltene transformation during coal tar hydrotreatment by conventional analysis and high-resolution Fourier transform mass spectrometry coupled with collision-induced dissociation technology

Insight into the Structure of Asphaltene after Its Disaggregation by Chemical Processing

Characterizing Asphalt Aging Behaviors and Rheological Properties Based on Spectrophotometry

Influence of Asphaltene on the Residue Hydrotreating Reaction

Comparison of the composition and structure for coal-derived and petroleum heavy subfraction by an improved separation method

Tracing the Composition and Structure Evolution of Oxygen-enriched Asphaltenes During the Hydrotreating of Middle-low Temperature Coal Tar

Reactivity and structural changes of asphaltene during the supercritical water upgrading process

Comparison of the Physical Properties and Chemical Structures of the Tahe Asphalt Before and after Oxidative Aging

Slurry-Phase Hydrogenation of Different Asphaltenes to Liquid Fuels on Dispersed MoS2 Nanocatalysts

Slurry-Phase Hydrogenation of Different Asphaltenes to Liquid Fuels on Dispersed MoS 2 Nanocatalysts

Research on the Mechanism of Low-Temperature Oxidation of Asphaltene

Analysis of Distribution and Structures of Heteroatom Compounds in Asphaltene of Medium/Low Temperature Coal Tar by Negative Anion Mode ESI FT-ICR MS

Catalytic asphaltene upgrading under methane environment: Solvent effect and its interaction with oil components

STUDY ON CATALYTIC PYROLYSIS MECHANISM OF BIO-OIL(Ⅱ)——Molecular Structure Model of Asphaltene in Bio-oil

The Study on Properties and Structure Changes of Residue During Hydrotreating

Liquefaction of Hongliulin coal asphaltenes and conversion of oxygenic structure

Study on modifying process of paving asphalt with 1HNMR/IR

Effect of Aromatic Pendants in a Maleic Anhydride- co -Octadecene Polymer on the Precipitation of Asphaltenes Extracted from Heavy Crude Oil